Abstract
Flue gases contain SO2 and NOx that can be treated together for elemental sulphur recovery in bioscrubbers, a technology that couples physical-chemical and biological processes for gaseous emissions treatment in a more economic manner than classical absorption. Sequential wet absorption of SO2 and NOx from flue gas is thoroughly studied in this work in a two-stage bioscrubber towards elemental sulphur valorisation pursuing reuse of biological process effluents as absorbents. The optimal operating conditions required for SO2 and NOx absorption in two consecutive spray absorbers were defined using NaOH-based absorbents. Overall, removal efficiencies of 98.9% and 55.9% for SO2 and NOx abatement were obtained in two in-series scrubbers operated under a gas contact time of 1 and 100 s, and a liquid-to-gas ratio of 7.5 and 15 L m−3, respectively. Higher NOx removal efficiency to clean gas emission was obtained by oxidants dosing in the absorber for NOx absorption. High NaHCO3 concentration in a two-stage bioscrubber effluent was exploited as alkaline absorbent for flue gas treatment. The performance of scrubbers using an absorbent mimicking a reused effluent exhibited the same removal efficiencies than those observed using NaOH solutions. In addition, the reuse of bioprocess effluent reduced reagents’ consumption by a 63.7%. Thus, the two-stage bioscrubber proposed herein offers an environmentally friendly and economic alternative for flue gas treatment.
Similar content being viewed by others
References
Adewuyi YG, Sakyi NY (2013) Simultaneous absorption and oxidation of nitric oxide and sulfur dioxide by aqueous solutions of sodium persulfate activated by temperature. Ind Eng Chem Res 52:11702–11711. https://doi.org/10.1021/ie401649s
Aǧar A, Küçükatay V, Yargiçoǧlu P et al (2000) The effect of sulfur dioxide inhalation on visual evoked potentials, antioxidant status, and lipid peroxidation in alloxan-induced diabetic rats. Arch Environ Contam Toxicol 39:257–264. https://doi.org/10.1007/s002440010103
Altuǧ H, Gaga EO, Döǧeroǧlu T et al (2013) Effects of air pollution on lung function and symptoms of asthma, rhinitis and eczema in primary school children. Environ Sci Pollut Res 20:6455–6467. https://doi.org/10.1007/s11356-013-1674-1
An T, Wan S, Li G, Sun L, Guo B (2010) Comparison of the removal of ethanethiol in twin-biotrickling filters inoculated with strain RG-1 and B350 mixed microorganisms. J Hazard Mater 183:372–380. https://doi.org/10.1016/j.jhazmat.2010.07.035
Bai J, Meng Z (2005) Effects of sulfur dioxide on apoptosis-related gene expressions in lungs from rats. Regul Toxicol Pharmacol 43:272–279. https://doi.org/10.1016/j.yrtph.2005.09.002
Chang CS, Rochelle GT (1981) SO2 absorption into aqueous solutions. AIChE J 27:292–298. https://doi.org/10.1002/aic.690270217
Chen JC, Liu ZS, Huang JS (2007) Emission characteristics of coal combustion in different O2/N2, O2/CO2 and O2/RFG atmosphere. J Hazard Mater 142:266–271. https://doi.org/10.1016/j.jhazmat.2006.08.021
Ding J, Zhong Q, Zhang S, Song F, Bu Y (2014) Simultaneous removal of NOX and SO2 from coal-fired flue gas by catalytic oxidation-removal process with H2O2. Chem Eng J 243:176–182. https://doi.org/10.1016/j.cej.2013.12.101
Ebrahimi S, Picioreanu C, Kleerebezem R, Heijnen JJ, van Loosdrecht MCM (2003) Rate-based modelling of SO2 absorption into aqueous NaHCO3/Na2CO3 solutions accompanied by the desorption of CO2. Chem Eng Sci 58:3589–3600. https://doi.org/10.1016/S0009-2509(03)00231-8
Fernández-Palacios E, Lafuente J, Mora M, Gabriel D (2019) Exploring the performance limits of a sulfidogenic UASB during the long-term use of crude glycerol as electron donor. Sci Total Environ 688:1184–1192. https://doi.org/10.1016/j.scitotenv.2019.06.371
Gao H, Li C, Zeng G, Zhang W, Shi L, Li S, Zeng Y, Fan X, Wen Q, Shu X (2011) Flue gas desulphurization based on limestone-gypsum with a novel wet-type PCF device. Sep Purif Technol 76:253–260. https://doi.org/10.1016/j.seppur.2010.10.013
Han Y, Li X, Fan M, Russell AG, Zhao Y, Cao C, Zhang N, Jiang G (2015) Abatement of SO2–NOx binary gas mixtures using a ferruginous active absorbent: Part I. Synergistic effects and mechanism. J Environ Sci 30:55–64. https://doi.org/10.1016/j.jes.2014.10.012
Hao R, Yang S, Yuan B, Zhao Y (2017) Simultaneous desulfurization and denitrification through an integrative process utilizing NaClO2/Na2S2O8. Fuel Process Technol 159:145–152. https://doi.org/10.1016/j.fuproc.2017.01.018
Hikita H, Asai S, Tsuji T (1977) Absorption of sulfur dioxide into aqueous sodium hydroxide and sodium sulfite solutions. AIChE J 23:538–544. https://doi.org/10.1002/aic.690230419
Hu Y, Naito S, Kobayashi N, Hasatani M (2000) CO 2 , NO x and SO 2 emissions from the combustion of coal with high oxygen concentration gases. Fuel 79:1925–1932. https://doi.org/10.1016/S0016-2361(00)00047-8
Jiang F, Zhang L, Peng G-L, Liang SY, Qian J, Wei L, Chen GH (2013) A novel approach to realize SANI process in freshwater sewage treatment - Use of wet flue gas desulfurization waste streams as sulfur source. Water Res 47:5773–5782. https://doi.org/10.1016/j.watres.2013.06.051
Jin Y, Veiga MC, Kennes C (2005) Bioprocesses for the removal of nitrogen oxides from polluted air. J Chem Technol Biotechnol 80:483–494. https://doi.org/10.1002/jctb.1260
Joshi JB, Mahajani VV, Juvekar VA (1985) Absorption of NOx gases. Chem Eng Commun 33:1–92. https://doi.org/10.1080/00986448508911161
Kan H, Wong C-M, Vichit-Vadakan N, Qian Z, PAPA Project Teams (2010) Short-term association between sulfur dioxide and daily mortality: the public health and air pollution in Asia (PAPA) study. Environ Res 110:258–264. https://doi.org/10.1016/j.envres.2010.01.006
Karatepe N (2000) A comparison of flue gas desulfurization processes. Energy Sources 22:197–206. https://doi.org/10.1080/00908310050013983
Lee KH, Sublette KL (1991) Simultaneous combined microbial removal of sulfur dioxide and nitric oxide from a gas stream. Appl Biochem Biotechnol 28–29:623–634. https://doi.org/10.1007/BF02922637
Lens PNL, Gastesi R, Lettinga G (2003) Use of sulfate reducing cell suspension bioreactors for the treatment of SO2 rich flue gases. Biodegradation 14:229–240. https://doi.org/10.1023/A:1024222020924
Li Y, Zhong W, Ju J, Wang T, Liu F (2014) Experiment on simultaneous absorption of NO and SO2 from sintering flue gas by oxidizing agents of KMnO4/NaClO. Int J Chem React Eng 12:539–547. https://doi.org/10.1515/ijcre-2014-0066
Lin J, Li L, Ding W, Zhang J, Liu J (2015) Continuous desulfurization and bacterial community structure of an integrated bioreactor developed to treat SO2 from a gas stream. J Environ Sci (China) 37:130–138. https://doi.org/10.1016/j.jes.2015.05.029
Liu Y, Bisson TM, Yang H, Xu Z (2010) Recent developments in novel sorbents for flue gas clean up. Fuel Process Technol 91:1175–1197. https://doi.org/10.1016/j.fuproc.2010.04.015
Majeed JG, Korda B, Békássy-Molnár E (1995) Comparison of the efficiencies of sulfur dioxide absorption using calcium carbonate slurry and sodium hydroxide solution in an ALT reactor. Gas Sep Purif 9:111–120. https://doi.org/10.1016/0950-4214(95)93948-J
Mathieu Y, Tzanis L, Soulard M, Patarin J, Vierling M, Molière M (2013) Adsorption of SOx by oxide materials: a review. Fuel Process Technol 114:81–100. https://doi.org/10.1016/j.fuproc.2013.03.019
Moore DJ (1987) Conditions in which power stations contribute to high ground level SO2 concentrations in the U.K. Atmos Environ 21:1849–1853. https://doi.org/10.1016/0004-6981(87)90126-0
Mora M, Lafuente F, Gabriel D (2018) Screening of biological sulfate reduction conditions for sulfidogenesis promotion using a methanogenic granular sludge. Chemosphere 210:557–566. https://doi.org/10.1016/j.chemosphere.2018.07.025
Mora M, Fernández-Palacios E, Guimerà X, Lafuente J, Gamisans X, Gabriel D (2020) Feasibility of S-rich streams valorization through a two-step biosulfur production process. Chemosphere 253:1–10. https://doi.org/10.1016/j.chemosphere.2020.126734
Newman BL, Carta G (1988) Mass transfer in the absorption of nitrogen oxides in alkaline solutions. AIChE J 34:1190–1199. https://doi.org/10.1002/aic.690340715
Ottengraf SPP, Diks RMM (1992) Process technology of biotechniques. Biotechnoques Air Pollut Abat Odour Control Policies 51:17–31. https://doi.org/10.1016/S0166-1116(08)70673-3
Perry RH, Green DW (1997) Perry’s chemical engineer’s handbook, 7th edn. Mc Graw-Hill
Philip L, Deshusses MA (2003) Sulfur dioxide treatment from flue gases using a biotrickling filter - bioreactor system. Environ Sci Technol 37:1978–1982. https://doi.org/10.1021/es026009d
Qian J, Lu H, Jiang F, Ekama GA, Chen GH (2015) Beneficial co-treatment of simple wet flue gas desulphurization wastes with freshwater sewage through development of mixed denitrification-SANI process. Chem Eng J 262:109–118. https://doi.org/10.1016/j.cej.2014.09.066
Rahmani F, Mowla D, Karimi G, Golkhar A, Rahmatmand B (2014) SO2 removal from simulated flue gas using various aqueous solutions: absorption equilibria and operational data in a packed column. Sep Purif Technol 153:162–169. https://doi.org/10.1016/j.seppur.2014.10.028
Rao AG, Ravichandra P, Joseph J, Jetty A, Sarma PN (2007) Microbial conversion of sulfur dioxide in flue gas to sulfide using bulk drug industry wastewater as an organic source by mixed cultures of sulfate reducing bacteria. J Hazard Mater 147:718–725. https://doi.org/10.1016/j.jhazmat.2007.01.070
Sakai M, Su C, Sasaoka E (2002) Simultaneous removal of SOx and NOx using slaked lime at low temperature. Ind Eng Chem Res 41:5029–5033
Shen TT, Ayer LG (1975) Determination of S02 emission from oil combustion sources by fuel analyses and S02/C02 relations. J Air Pollut Control Assoc 25:851–855. https://doi.org/10.1080/00022470.1975.10470150
Srivastava RK, Jozewicz W (2001) Flue gas desulfurization: the state of the art. J Air Waste Manag Assoc 51:1676–1688. https://doi.org/10.1080/10473289.2001.10464387
Suchak NJ, Jethani KR, Joshi JB (1990) Absorption of nitrogen oxides in alkaline solutions: selective manufacture of sodium nitrite. Ind Eng Chem Res 29:1492–1502. https://doi.org/10.1021/ie00103a059
Sun Y, Zwolińska E, Chmielewski AG (2016) Abatement technologies for high concentrations of NOx and SO2 removal from exhaust gases: a review. Crit Rev Environ Sci Technol 46:119–142. https://doi.org/10.1080/10643389.2015.1063334
Sun J, Li L, Zhou G, Wang X, Zhang L, Liu Y, Yang J, Lü X, Jiang F (2018) Biological sulfur reduction to generate H 2 S as a reducing agent to achieve simultaneous catalytic removal of SO 2 and NO and sulfur recovery from flue gas. Environ Sci Technol 52:4754–4762. https://doi.org/10.1021/acs.est.7b06551
Thomas D, Vanderschuren J (1997) Modeling of NOx absorption into nitric acid solutions containing hydrogen peroxide. Ind Eng Chem Res 36:3315–3322. https://doi.org/10.1021/ie960436g
Thomas D, Vanderschuren J (1998) Removal of tetravalent NOx from flue gases using solutions containing hydrogen peroxide. Chem Eng Technol 21:975–981. https://doi.org/10.1002/(SICI)1521-4125(199812)21:12<975::AID-CEAT975>3.0.CO;2-H
Tian H, Gao J, Lu L, Zhao D, Cheng K, Qiu P (2012) Temporal trends and spatial variation characteristics of hazardous air pollutant emission inventory from municipal solid waste incineration in China. Environ Sci Technol 46:10364–10371. https://doi.org/10.1021/es302343s
Van Houten RT, Yun SY, Lettinga G (1997) Thermophilic sulphate and sulphite reduction in lab-scale gas-lift reactors using H2 and CO2 as energy and carbon source. Biotechnol Bioeng 55:807–814. https://doi.org/10.1002/(SICI)1097-0290(19970905)55:5<807::AID-BIT11>3.0.CO;2-8
Wang W, Yang C, Zhang J (2012) Absorption of sulphur dioxide from flue gas with sodium alkali solution in packed columns. Adv Mater Res 383–390:6409–6415. https://doi.org/10.4028/www.scientific.net/AMR.383-390.6409
Wang J, Cao Y, Zhong Q (2013) Formulation and optimization of biological removal of flue gas pretreatment wastewater and sulfur recycling process by Box-Behnken design. Water Sci Technol 67:2706–2711. https://doi.org/10.2166/wst.2013.175
Wang Z, Peng Y, Ren X, Gui S, Zhang G (2015) Absorption of sulfur dioxide with sodium hydroxide solution in spray columns. Ind Eng Chem Res 54:8670–8677. https://doi.org/10.1021/acs.iecr.5b02146
Winnes H, Fridell E (2010) Emissions of NOX and particles from manoeuvring ships. Transp Res Part D Transp Environ 15:204–211. https://doi.org/10.1016/j.trd.2010.02.003
Zevenhoven, Kilpinen (2001) Chapter 2 Flue gases and fuel gases 2.1. Flue gases fuel gases 1–12
Zhao J, Jin B, Zhong Z (2007) The degree of desulphurization of a limestone/gypsum wet FGD spray tower using response surface methodology. Chem Eng Technol 30:517–522. https://doi.org/10.1002/ceat.200600347
Zhao Y, Han Y, Ma T, Guo T (2011) Simultaneous desulfurization and denitrification from flue gas by ferrate (VI). Environ Sci Technol 45:4060–4065. https://doi.org/10.1021/es103857g
Zhu Q, Van Teeffelen RM, Van Santen RA, Hensen EJM (2004) Effect of high-temperature treatment on Fe/ZSM-5 prepared by chemical vapor deposition of FeCl3 II. Nitrous oxide decomposition, selective oxidation of benzene to phenol, and selective reduction of nitric oxide by isobutane. J Catal 221:575–583. https://doi.org/10.1016/j.jcat.2003.09.025
Funding
Authors acknowledge the Spanish Government, through the project RTI2018-099362-B-C21 MINECO/FEDER, EU for the financial support provided to perform this research.
Author information
Authors and Affiliations
Corresponding author
Additional information
Responsible Editor: Philippe Garrigues
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Guimerà, X., Mora, M., Dorado, A.D. et al. Optimization of SO2 and NOx sequential wet absorption in a two-stage bioscrubber for elemental sulphur valorisation. Environ Sci Pollut Res 28, 24605–24617 (2021). https://doi.org/10.1007/s11356-020-09607-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-020-09607-1