Skip to main content
SpringerLink
Log in

A laser imaging-LDV coupling measurement of single bubble forming and rising in shear-thinning fluid

  • Published:
Journal of Thermal Science Aims and scope Submit manuscript

Abstract

The shape evolution of bubble formed in carboxymethylcellulose (CMC) aqueous solution was real-time observed using laser image technique. The flow fields of liquid around growing and rising bubble were measured by laser Doppler velocimetry (LDV), and the liquid mean velocity and its contour curves were obtained. The results show that bubble grows as spherical shape because of the dominant role of surface tension in the early period, and then is stretched gradually as a teardrop shape due to the common effect of buoyancy and shear-thinning of fluid. The axial mean velocity of liquid phase takes on Gaussian distribution with the symmetrical axis passing through orifice center. However, the radial mean velocity increases first and then decreases with the increase of the distance from measured point to the symmetrical axis above. Further, the axial component along symmetrical axis decreases initially and increases with the rise of height, as well as its corresponding contour map diverging gradually. The radial component, yet, decreases steadily with the rise of height, and the maximum value deviates towards the two sides until disappear, as it contour shape of butterfly’s “front wing”.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Shah, Y.T., Kelkar, B.G., Godbole, S.P., Deckwer, W.D., Design parameters estimation for bubble column reactors, AIChE J., vol. 28, 1982, pp. 353–379.

    Article  Google Scholar 

  2. Kilonzo, P.M., Margaritis, A., The effects of non-Newtonian fermentation broth viscosity and small bubble segregation on oxygen mass transfer in gas-lift bioreactors: A critical review, Biochem. Eng. J. vol. 17, 2004, pp. 27–40.

    Article  Google Scholar 

  3. Hassagar, O., Negative wake behind bubbles in non-Newtonian liquids, Nature, vol. 279, 1979, pp. 402–403.

    Article  ADS  Google Scholar 

  4. Bisgaard, C., Hassager, O., An experimental investigation of velocity fields around spheres and bubbles moving in non-Newtonian liquid, Rheol. Acta, vol. 21, 1982, pp. 537–548.

    Article  Google Scholar 

  5. Arigo, M.T., McKinley, G.H., An experimental investigation of negative wakes behind spheres settling in a shear-thinning viscoelastic fluid, Rheol. Acta, vol. 37, 1998, pp. 307–327.

    Article  Google Scholar 

  6. Frank, X., Li, H.Z., Complex flow around a bubble rising in a non-Newtonian fluid, Phys. Rev. E. vol. 71, 2005, pp. 036309.

    Article  ADS  Google Scholar 

  7. Frank, X., Li, H.Z., Negative wake behind a sphere rising in viscoelastic fluids: A lattice Boltzmann investigation, Phys. Rev. E. vol. 74, 2006, pp. 056307.

    Article  ADS  Google Scholar 

  8. Sousa, R.G., Pinto, A.M.F.R., Campos, J.B.L.M., Interaction between Taylor bubbles rising in stagnant non-Newtonian fluids, Int. J. Multiphase Flow, vol. 33(9) (2007) 970–986.

    Article  Google Scholar 

  9. Lin, T.J., Lin, G.M., Mechanisms of in-line coalescence of two-unequal bubbles in a non-Newtonian fluid, Chem. Eng. J. vol. 155, 2009, pp. 750–756.

    Article  Google Scholar 

  10. Fan, W.Y., Ma, Y.G., Li, X.L., Li, H.Z., Study on the flow field around two parallel moving bubbles and interaction between bubbles rising in CMC solutions by PIV, Chin. J. Chem. Eng. Vol. 17, 2009, pp. 904–913.

    Article  Google Scholar 

  11. Ghosh, A.K., Ulbrecht, J.J. Bubble formation from a sparger in polymer solutions, Chem. Eng. Sci., vol. 44, 1989, pp. 957–968.

    Article  Google Scholar 

  12. Terasaka, K., Tsuge, H., Bubble formation at a single orifice in non-Newtonian liquids, Chem. Eng. Sci., vol. 46, 1991, pp. 85–93.

    Article  Google Scholar 

  13. Li, H.Z., Mouline, Y., Midoux, N., Modelling the bubble formation dynamics in non-Newtonian fluids, Chem. Eng. Sci., vol. 57, 2002, pp. 339–346.

    Article  Google Scholar 

  14. Fan, W.Y., Ma, Y.G., Jiang, S.K., Li, H.Z., An experimental investigation for bubble rising in non-Newtonian fluids and empirical correlation of drag coefficient, J Fluid Eng-T ASME, vol. 132, 2010, pp. 021305.

    Article  Google Scholar 

  15. Zhang, L., Yang, C., Mao, Z.S., Numerical simulation of a bubble rising in shear-thinning fluids, J. Non-Newtonian Fluid Mech., vol. 165, 2010, pp. 555–567.

    Article  MATH  Google Scholar 

  16. Lin, T.J., Lin, G.M., An experimental study on flow structures of a single bubble rising in a shear-thinning viscoelastic fluid with a new measurement technique, Int. J. Multiphase Flow, vol. 31, 2005, pp. 239–252.

    Article  MATH  Google Scholar 

  17. Vélez-Cordero, J.R., Sámano, D., Yue, P.T., Feng, J.J., Zenit, R., Hydrodynamic interaction between a pair of bubbles ascending in shear-thinning inelastic fluids, J. Non-Newtonian Fluid Mech., vol. 166, 2011, pp. 118–132.

    Article  MATH  Google Scholar 

  18. Rabha, S.S., Buwa, V.V., Volume-of-fluid (VOF) simulations of rise of single/multiple bubbles in sheared liquid, Chem. Eng. Sci., vol. 65, 2010, pp. 527–537.

    Article  Google Scholar 

  19. Stanovsky, P., Ruzicka, M., Martins, A., Teixeira, J.A., Meniscus dynamics in bubble formation: A parametric study, Chem. Eng. Sci., vol. 66, 2011, pp. 3258–3267.

    Article  Google Scholar 

  20. Ruzicka, M., Bunganic, R., Drahos, J., Meniscus dynamics in bubble formation. Part I: Experiment, Chem. Eng. Res. Des., vol. 87, 2009, pp. 1349–1356.

    Article  Google Scholar 

  21. Vafaei, S., Wen, D. S., Bubble formation on a submerged micronozzle, J. Colloid Interf. Sci., vol. 343, 2010, pp. 291–297.

    Article  Google Scholar 

  22. Velez-Cordero, J.R., Zenit, R., Bubble cluster formation in shear-thinning inelastic bubbly columns, J. Non-Newtonian Fluid Mech., vol. 166, 2011, pp. 32–41.

    Article  Google Scholar 

  23. Wang, X.W., Zhao, S.W., Wang, H., Pan, T.R., Bubble formation on superhydrophobic-micropatterned copper surfaces, App. Therm. Eng., vol.35, 2012, pp. 112–119.

    Article  Google Scholar 

  24. Kumara, W.A.S., Elseth, G., Halvorsen, B.M., Melaaen, M.C., Comparison of particle image velocimetry and laser Doppler anemometry measurement methods applied to the oil-water flow in horizontal pipe, Flow Meas. Instrum., vol. 21, 2010, pp. 105–117.

    Article  Google Scholar 

  25. Funfschilling, D., Li, H.Z., Effects of the injection period on the rise velocity and shape of a bubble in a non-Newtonian fluid, Chem. Eng. Res. Des., vol. 84, 2006, pp. 875–883.

    Article  Google Scholar 

  26. Iguchi, M., Ueda, H., Uemura, T., Bubble and liquid flow characteristics in a vertical bubbling jet, Int. J. Multiphase Flow, vol. 21, 1995, pp. 861–873.

    Article  MATH  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. School of Chemistry and Chemical Engineering, Tianjin University of Technology, Tianjin, 300384, China

    Wenyuan Fan & XiaoHong Yin

Authors
  1. Wenyuan Fan
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. XiaoHong Yin
    View author publications

    You can also search for this author in PubMed Google Scholar

Additional information

Financially supported by National Natural Science Foundation of China (21076139, 21106106), Tianjin Natural Science Foundation (12JCQNJC03700), and Foundation of Tianjin Educational Committee of China (20100508).

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Fan, W., Yin, X. A laser imaging-LDV coupling measurement of single bubble forming and rising in shear-thinning fluid. J. Therm. Sci. 23, 233–238 (2014). https://doi.org/10.1007/s11630-014-0700-z

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11630-014-0700-z

Keywords

Search

Navigation