Abstract
Optical losses by reflection and transmission of the incident light should be reduced to improve the efficiency of solar cells. Compared with antireflection coatings, surface texturing is a more persistent and effective solution aiming at reducing light reflection losses. Alkali (NaOH, KOH) or acidic (HF, HNO3, CH3COOH) chemicals are used in conventional solar cell production lines for wet chemical texturing. However, Surface texturing is too difficult to apply to solar cell fabrication with thinner wafers due to the large amount of silicon loss caused by saw damage removal (SDR) and the texturing process for multicrystalline silicon (mc-Si). In order to solve the problems, reactive ion etching (RIE) has been applied for surface texturing of solar cell wafers. The RIE method can be effective in the reducing surface reflection with low silicon loss. In this study, we, therefore, fabricated a large-area (243.3 cm2) mc-Si solar cell by maskless surface texturing using a SF6/O2 RIE process. Also, we achieved a conversion efficiency (Eff), open circuit voltage (Voc), short circuit current density (Jsc) and fill factor (FF) as high as 17.2%, 616 mV, 35.1 mA/cm2, and 79.6%, respectively, which are suitable for fabricating thin crystalline silicon solar cells at low cost and with high efficiency.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
J. Zhao, W. Aihua and M. A. Green, Appl. Phys. Lett. 73, 1992 (1998).
D. H. Macdonald, A. Cuevas, M. J. Kerr, C. Samundsett, D. Ruby, S. Winderbaum and A. Leo, Sol. Energy 76, 278 (2004).
K. J. Weber and A. W. Blakers, Prog. Photovoltics Res. Appl. 13, 691 (2005).
M. A. Blauw, T. Zijlstra, R. A. Bakker and E. van der Drift, J. Vac. Sci. Technol., B 18, 3454 (2000).
G. Craciun, M. A. Blauw, E. van der Drift and P. J. French, in Proceedings of the 11th International Conference on Solid-State Sensors Actuators (Munich, Germany, June 10–14, 2001), p. 612.
P. Path, G. Wileke, E. Bucher, J. Szlufcic, R. M. Murti, K. De Clercq, J. Nijs and R. Mertens, in Proceedings of 24th IEEE Photovoltaic Specialist Conference (Waikoloa, Hawaii, December 5–9, 1994), p. 1347.
W. A. Nositschka, O. Voigt, P. Manshanden and H. Kurz, Sol. Energy Mater. Sol. Cells 80, 228 (2003).
H. Jansen et al., J. Micromech. Microeng. 5, 115 (1995).
W. A. Nositschka, C. Beneking, O. Voigt and H. Kurz, Sol. Energy Mater. Sol. Cells 76, 155 (2003).
S. Schaefer and R. Lüdemamn, J. Vac. Sci. Technol., A 17, 750 (1999).
V. Y. Yerokhov, R. Hezel, M. Lipinski, R. Ciach, H. Nagel, A. Mylyanych and P. Panek, Sol. Energy Mater. Sol. Cells 72, 291 (2002).
Y. Nishimoto, T. Ishihara and K. Namba, J. Electrochem. Soc. 146, 457 (1999).
M. J. Stocks, A. J. Carr and A. W. Blakers, Sol. Energy Mater. Sol. Cells 40, 35 (1996).
M. A. Green, A. Wang, J. Zhao, S. Wenham, P. Campbell and D. Thorp, in The 13th European Photovoltaic Solar Energy Conference (Nice, France, October 23–27, 1995), p. 13.
H. Jansen, M. de Boer, H. Wensink, B. Kloeck and M. Elwenspoek, Microelecron. J. 31, 770 (2001).
J. S. Yoo, G. J. Yu and J. Yi, Sol. Energy Mater. Sol. Cells 95, 2 (2011).
G. Kumaravelu, M. M. Alkaisi and A. Bittar, in Photovoltaic Specialists Conference, Conference Record of the Twenty-Ninth IEEE (Hyatt Regency, New Orleans, Louisiana, May 19–24, 2002), p. 259.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Yoo, J., Cho, J., Han, K. et al. RIE surface texturing for optimum light trapping in multicrystalline silicon solar cells. Journal of the Korean Physical Society 60, 2071–2074 (2012). https://doi.org/10.3938/jkps.60.2071
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.3938/jkps.60.2071