Abstract
Twenty-three V-Ni-C alloys were produced and analysed in the as-cast condition, as well as after annealing at 1000 °C for 1000 h. The phases were identified using SEM–EDX and XRD. The extensions of the binary phases were determined. The liquidus surface projection was derived from the overall compositions, primary phases and the solidification sequences. Four invariant reactions on solidification were found. The isothermal section at 1000 °C was also derived, which included the ~ Ni2V4C ternary phase.
Similar content being viewed by others
References
S.G. Huang, K. Vanmeensel, L. Li, O. Van der Biest, and J. Vleugels, Influence of Starting Powder on the Microstructure of WC-Co Hardmetals Obtained by Spark Plasma Sintering, Mater. Sci. Eng., 2008, 475, p 87-91
E.K. Storms, The Refractory Carbides, Academic Press, New York, 1967
C. Santafe and C. Borgianni, Study of the Oxidation Kinetics of Vanadium Carbide, Oxid. Met., 1975, 9, p 415-425
E. Lugscheider, O. Knotek, K. Bobzin, and S. Bärwulf, Tribological Properties, Phase Generation and High Temperature Phase Stability of Tungsten- and Vanadium-oxides Deposited by Reactive MSIP-PVD Process for Innovative Lubrication Applications, Surf. Coat. Technol., 2000, 133–134, p 362-368
I.C. Grigorescu, J. Ramirez, F. Salcedo, and C. Weil, Tribological Behavior of Vanadium Oxycarbide Coatings, Surf. Coat. Technol., 1997, 94, p 437-440
A. Ruize, I.C. Grigorescu, L. Matamoras, C. Rojas, and D. Morel, Graded Metal-carbide Composites Produced by Solid State Transformation, Int. J. Refract. Met. Hard Mater., 2009, 27, p 261-266
S. Luyckx, C. Osborne, L.A. Cornish, and D. Whitefield, Fine Grained WC-VC-Co Hard Metal, Powder Metall., 1996, 39, p 210-212
E.G. Obbard, S. Luyckx, S. Hamar-Thibault, and C.H. Allibert, Determination of the Composition Range Suitable to the Formation of WC-(V, W)Cx-Co Materials, Int. J. Refract. Met. Hard Mater., 2001, 19, p 349-357
T.W. Penrice, Alternative Binders for Hard Metals, J. Mat. Shaping Technol., 1987, 5, p 35-39
B. Wittmann, W. Schubert, and B. Lux, WC Grain Growth and Grain Growth Inhibition in Nickel and Iron Binder Hardmetals, Int. J. Refract. Met. Hard Mater., 2002, 20, p 51-60
H. Rong, Z. Penga, X. Rena, Y. Penga, C. Wanga, Z. Fua, L. Qi, and H. Miaob, Ultrafine WC–Ni Cemented Carbides Fabricated by Spark Plasma Sintering, Mater. Sci. Eng. A, 2012, 532, p 543-547
H. Engqvist, N. Axén, and S. Hogmark, Tribological Properties of Binderless Carbide, Wear, 1999, 232(2), p 157-162
A.M. Human and H.E. Exner, Electrochemical Behaviour of Tungsten Carbide Hardmetals, Mater. Sci. Eng., A, 1996, 209, p 180-191
H. Pollak, A. Fleischmann, S.B. Luyckx and A. Koursaris, Investigation of the Phases Present in Fe-V-C alloys by Mössbauer Spectroscopy and X-ray Diffraction, Nucl. Instrum. Methods Phys. Res., Sect. B, 1993, 76, pp. 270-272.
D.J. Whitefield, S. Luyckx, M.J. Witcomb and L.A. Cornish, Microstructure and Properties of Fine Grain WC-VC-Co Hard Metal with Cobalt Content Ranging from 10-15%, Proc.14th Int. Plansee. Semin., 1997, 2, pp. 477-484.
D. Giuntini, X. Wei, A.L. Maximenko, L. Weia, A.M. Ilyina, and E.A. Olevsky, Initial Stage of Free Pressureless Spark-Plasma Sintering of Vanadium Carbide: Determination of Surface Diffusion Parameters, Int. J. Refract. Met. Hard Mater., 2013, 41, p 501-506
A.O. Apata, T.N. Muobeleni, A.A. Fabuyide, E.N. Ogunmuyiwa, G.O. Rading, P.K. Jain, M.J. Witcomb, and L.A. Cornish, Development of VC-Ni Eutectic Alloys for Wear Resistance, Adv. Mater. Res., 2014, 1019, p 347-354
E.K. Storms and R.J. McNeal, The Vanadium-Vanadium Carbide System, J. Phys. Chem., 1962, 66, p 1401-1408
E. Rudy, S. Windisch, and C.E. Brukl, Thermodynamic Reassessment of the V-C System, Planseeber. Pulvermetall., 1968, 16, p 3-33
O.N. Carlson, A.H. Ghaneya, and J.F. Smith, The C-V (Carbon-Vanadium) System, Bull. Alloy Phase Diagr., 1985, 6(2), p 115-124
L.M. Adelsberg and L.H. Cadoff, Chemical Diffusion and Phase Equilibria in the Vanadium-Carbon System above 1900 °C, J. Am. Ceram. Soc., 1968, 51(4), p 213-220
A. Ghaneya, Some Studies on the V-C System, Ph.D. Thesis, Iowa State University, Ames, IA, USA (1984).
B. Lee and D. Lee, A Thermodynamic Study on the V-C and Fe-V Systems, Calphad, 1991, 15, p 283-291
S. Huang, J. Vleugels, L. Li. and O. Biest, Experimental Investigation and Thermodynamic Assessment of the V-W-C System, J. Alloys Compd., 2005, 395, pp. 68-74.
J. Hu, C. Li, F. Wang, and W. Zhang, Thermodynamic Re-assessment of the V-C System, J. Alloys Compd., 2006, 421, p 120-127
V.N. Lipatnikov, A.I. Gusev, P. Ettmayer and W. Lengauer, Phase Transformations in Non-stiochiometric Vanadium Carbide, J. Phys.: Condens. Matter, 1999, 11, pp. 163-184.
V.N. Lipatnikov, A.I. Gusev, P. Ettmeier, and W. Lengauer, Order-disorder Phase Transformations and Specific Heat of Nonstoichiometric Vanadium Carbide, Phys. Solid State, 1999, 41, p 474-480
J.F. Smith, O.N. Carlson, and P.G. Nash, The Ni-V (Nickel-Vanadium) System, Bull. Alloy Phase Diagr., 1982, 3(3), p 342-348
H. Giebelhausen, The Systems Vanadium-Silicon, Nickel-Copper and Boron-Nickel, Z. Anorg. Chem., 1915, 91, p 251-262
W.B. Pearson, J.W. Christian, and W. Hume-Rothery, New Sigma-Phases in Binary Alloys of the Transition Elements of the First Long Period, Nature, 1951, 167, p 110
W.B. Pearson and W. Hume-Rothery, The Constitution and Structure of Ni–V Alloys in the Region 0–60 at% Vanadium, J. Inst. Met., 1952, 80, p 641-648
W. Rostoker and A. Yamamoto, A Survey of Vanadium Binary Systems, Trans. ASM, 1954, 46, p 1136-1167
H.P. Sttiwe, Description of the Sigma Phase as a Structure with Sphere Packing, Trans. TMS-AIME, 1959, 215, p 408-411
S.T. Zegler and J.W. Downey, Ternary Cr3O-type Phases with Vanadium Alloys, Trans. Am. Inst. Min. Metall. Pet. Eng., 1963, 227, p 1407-1411
A. Maldonado and K. Schubert, Crystal Structure Investigations in Some Alloy Systems Homologous and Quasihomologous to T5-T10, Z. Metallkd., 1964, 55, p 619-626
B.C. Giessen and N.J. Grant, The Crystal Structure of VNi2, VPd2, VPt2 and Related AB2 Phases, J. Less Common Met., 1965, 8, p 114-119
R. Ruhl and M. Cohen, Metastable Extensions of Carbon Solubility in Nickel and Cobalt, Scr. Metall., 1967, 1, p 73-74
L.E. Tanner, The Ordering of Ni3V, Phys. Status Solidi B, 1968, 30, p 685-701
E.R. Stevens and O.N. Carlson, V-Ni System, Metall. Mater. Trans. B, 1970, 1(5), p 1267-1271
H.A. Moreen, R. Taggart, and D.H. Polonis, Vanadium-Nickel System, J. Mater. Sci., 1971, 6, p 1425-1432
M. Daire and M. Gerspacher, Précisions sur le Diagramme d’hquilibre Vanadium-Nickel Entre 0 et 40% de Nickel, J. Less-Common Metals, 1969, 17, p 334-335
S.K. Singh and K.P. Gupta, The Cr-Ni-V System, J. Phase Equilibria, 1995, 16(2), p 129-136
Zhixin Wang, Huiying Zhou, Zhongmin Wang, and Qingrong Yao, The 773 K Isothermal Section of the Nd–Ni–V Ternary System, J. Alloys and Comp., 2008, 458, p 425-427
Shunkang Pan, Huaiying Zhou, and Qin Zhou, Qingrong Yao and ZhongminWang, Isothermal Section of the Phase Diagram of the Ternary System Y-Ni–V at 773 K, J. Alloys and Comp., 2009, 471, p 119-121
Yan Zhong, Huaiying Zhou, Qingrong Yao, Chengying Tang and R.P. Zou, The Isothermal Section of the Gd–Ni–V Ternary System at 773K, J. Alloys and Comp., 2009, 470, pp. 199–201.
C.C. Zhao, S.Y. Yang, Y. Lu, Y.H. Guo, C.P. Wang, and X.J. Liu, Experimental Investigation and Thermodynamic Calculation of the Phase Equilibria in the Fe–Ni–V system, CALPHAD, 2014, 46, p 80-86
Lei Zou, Cuiping Guo, Changrong Li, and Du Zhenmin, Experimental Investigation and Thermodynamic Modeling of the Ni–Ti–V, CALPHAD, 2019, 64, p 97-114
E.G. Kabanova, V.N. Kuznetsov, and G.P. Zhmurko, Thermodynamic Modeling of Phase Equilibria in the Ni-V System, Russ. J. Phys. Chem. A, 2010, 84(5), pp. 755-759.
Lei Huang, Yafei Pan, Du Yong, Jiuxing Zhang, and Fenghua Luo, Thermodynamic Modeling of the Ni–Nb–V Ternary System, CALPHAD, 2019, 67, p 101673
A. Watson and F.H. Hayes, Some Experiences Modelling the Sigma Phase in the Ni–V System, J. Alloys and Comp., 2001, 320, p 199-206
Yafei Pan, Du Yong, Jian Lv, Tongxiang Liang, and Fenghua Luo, Reassessment of the Ni–V System and a New Thermodynamic Modeling of the Mo–Ni–V System, Thermochim. Acta, 2018, 661, p 137-146
Mehdi Noori and Bengt Hallstedt, Thermodynamic Modelling of the Ni-V System, CALPHAD, 2019, 65, p 273-281
M. Singleton and P. Nash, The C-Ni (Carbon-Nickel) System, Bull. Alloy Phase Diagr., 1989, 10(2), p 121-126
F. Edler, Precise Temperature Measurement Above 1000 °C Using Thermocouples, Proc. Estonian Acad. Sci. Eng., 2007, 13(4), p 310-319
V.S. Telegus and Y.B. Kuz’ma, The Investigation of the Transition Metals of the Fourth with Carbon, Visn. L’viv. Derzh. Univ. Ser. Khim., 1971, 12, p 28-33
H. Holleck and K. Biemüller, Herstellung and Eigenschaften Hochschmelzender Verbindungen and Systeme (Hartstoffe and Hartmettale) (1979) pp. 69-101.
H. Frey and H. Holleck, DTA Investigation of High Temperature Phase Equilibra in Ternary Transition Metal Carbon System, Proc. 4th, ICTA Conf., 1975, 1, pp. 339-348.
A.O. Apata, Investigation of the C-Ni-V Ternary Phase Diagram and Development of Abrasion-resistant Alloys, PhD Thesis, University of the Witwatersrand, Johannesburg (2014).
T.S. Muobeleni, Study of Eutectics in C-Ni-V System, 4th Year Project Report, University of the Witwatersrand, Johannesburg, 2013
A.A. Fabuyide, Investigation of the C-Ni-V Ternary Phase Diagram and Development of an Optimum Wear-resistant Alloy, PhD Thesis, University of the Witwatersrand, Johannesburg (2018).
J. Howe, C. Rawn, L. Jones, and H. Ow, Improved Crystallographic Data for Graphite, Powder Diffr., 2003, 18(2), p 150-154
H.T. Takeshita, T. Oishi, and N.J. Kuriyama, Disproportionation of CaNi3 Hydride: Formation of New Hydride, CaNiH3, J. Alloys Compd., 2002, 333, p 266-273
D.P. Rodionov, I.V. Gervas’eva, Y.V. Klebnikova, V.A. Sazonova and B.K. Sokolov, Effect of Alloying and Heat Treatment of the Formation of Recrystallization Cube Texture in Nickel Alloys, Fiz. Met. Metalloved. (2005) 99, 88-98.
S.B. Prima, L.A. Tret’yachenko and G.I. Kostrygina, Isothermal Section of the Vanadium-Nickel-Molybdenum System at 1150 °C, Dopov. Akad. Nauk. Ukr. RSR, Ser. A: Fiz-Mat. Tekh. Nauki (1979) 229.
Natl. Bur. Stand. (U.S.) Monogr. (1971) 25 9, 58.
W. Koester and W. Gmoehling, Z. Metallkd., 1960, 51, p 385-391
J. Rexer and D.T. Peterson, Ternary Metal-Carbon-Hydrogen Compounds of Some Transition Metals, IMD Spec. Rep. Ser., 1964, 10, p 327
K. Cenzual, L.M. Gelato, M. Penzo and E. Parthe, Inorganic Structure Types with Revised Space Groups I, Acta Crystallogr., Sect. B: Struct. Sci. (1991) 47, 433-439.
Natl. Bur. Stand. (U.S.) Monogr. (1985) 25 21, 129.
G.F. Bastin and H.J.M. Heijligers, Quantitative Electron Probe Microanalysis of Carbon in Binary Carbides. I—Principles and Procedures, X-ray Spectrometry (1986) 5(2) pp. 135-141.
L. Ingemarsson and M. Halvarsson, SEM/EDX Analysis of Boron, A Case Study, High Temperature Corrosion Centre (HTC), Chalmers University of Technology, 31 January 2011.
A.E. Vladár and M.T. Postek, Electron Beam-Induced Sample Contamination in the SEM, Microsc. Microanal., 2005, 11(Suppl 2), p 764-765
D. Hoyle, M. Malac, M. Trudeau, and P. Woo, UV Treatment of TEM/STEM Samples for Reduced Hydrocarbon Contamination, Microsc. Microanal., 2011, 17(Suppl 2), p 1026-1027
T. Tanaka, K.N. Ishihara, and P.H. Shingu, Formation of Metastable Phases of Ni-C and Co-C syStems by Mechanical Alloying, Metall. Trans. A, 1992, 23, p 2431-2435
G.I. Goldstein, D.E. Newberry, P. Echlin, D.C. Joy, C. Fiori, and E. Lifshin, Scanning Electron Microscopy and x-Ray Microanalysis, Plenum Press, New York, 1981, p 56-59
Acknowledgments
The authors are grateful to Carnegie Corporation of New York for supporting AMSEN, and the Department of Science and Innovation and the National Research Foundation, South Africa for supporting the DSI-NRF Centre of Excellence in Strong Materials, also to Mintek for access to research facilitates, and Mr Edson Muhuma for assistance with arc-melting. Mr R. van der Merwe of NECSA is thanked for help with EDX measurements.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Fabuyide, A.A., Apata, A.O., Muobeleni, T.N. et al. Experimental Liquidus Surface Projection and Isothermal Section at 1000 °C of the V-Ni-C System. J. Phase Equilib. Diffus. 42, 42–62 (2021). https://doi.org/10.1007/s11669-020-00860-y
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11669-020-00860-y