Skip to main content
SpringerLink
Log in

Surface enthalpy and enthalpy of water adsorption of nanocrystalline tin dioxide: Thermodynamic insight on the sensing activity

  • Articles
  • Published:
Journal of Materials Research Aims and scope Submit manuscript

Abstract

Tin dioxide (SnO2) is an important base material for a variety of gas sensors and catalysts. However, there is a lack of experimental data on the energetics of SnO2 surfaces and their water adsorption. In this work, the surface energies of anhydrous and hydrated SnO2 nanoparticles were measured by combining high-temperature oxide melt solution calorimetry and water adsorption calorimetry. The SnO2 nanoparticles were synthesized through oxidation of metallic tin using nitric acid followed by heat treatment at different temperatures to achieve surface areas ranging from 4000 to 10,000 m2·mol−1(25–65 m2·g−1). The enthalpy of the anhydrous surface is 1.72 ± 0.01 J·m−2, and that of the hydrated surface is 1.49 ± 0.01 J·m−2. The integral heat of water adsorption is −75 kJ·mol−1, with a chemisorbed maximum coverage of ∼5 H2O·nm−2. SnO2 has a lower surface energy and less exothermic enthalpy of water adsorption than the isostructural TiO2 (rutile) reported previously. This comparison suggests that the excellent sensing properties of SnO2 may be a consequence of its relatively low affinity for surface H2O molecules that compete with other gases for adsorption.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Table I
Fig. 1
Fig. 2
Fig. 3
Fig. 4
Table II
Table III
Table IV

Similar content being viewed by others

References

  1. N. Barsan, M. Schweizer-Berberich, and W. Gopel: Fundamental and practical aspects in the design of nanoscaled SnO2 gas sensors: A status report. Fresenius J. Anal. Chem. 365, 287 (1999).

    Article  CAS  Google Scholar 

  2. M. Batzill and U. Diebold: The surface and materials science of tin oxide. Prog. Surf. Sci. 79, 47 (2005).

    Article  CAS  Google Scholar 

  3. M. Batzill: Surface science studies of gas sensing materials: SnO2. Sensors. 6, 1345 (2006).

    Article  CAS  Google Scholar 

  4. M.E. Franke, T.J. Koplin, and U. Simon: Metal and metal oxide nanoparticles in chemiresistors: Does the nanoscale matter?Small. 2, 36 (2006).

    Article  CAS  Google Scholar 

  5. J. Huang and Q. Wan: Gas sensors based on semiconducting metal oxide one-dimensional nanostructures. Sensors. 9, 9903 (2009).

    Article  Google Scholar 

  6. S. Basu and P.K. Basu: Nanocrystalline metal oxides for methane sensors: Role of noble metals. J. Sens. 2009, 861968 (2009).

    Google Scholar 

  7. J. Zhang, X.H. Liu, S.H. Wu, M.J. Xu, X.Z. Guo, and S.R. Wang: Au nanoparticle-decorated porous SnO2 hollow spheres: A new model for a chemical sensor. J. Mater. Chem. 20, 6453 (2010).

    Article  CAS  Google Scholar 

  8. L.H. Qian, K. Wang, Y. Li, H.T. Fang, Q.H. Lu, and X.L. Ma: CO sensor based on Au-decorated SnO2 nanobelt. Mater. Chem. Phys. 100, 82 (2006).

    Article  CAS  Google Scholar 

  9. M. Epifani, J. Arbiol, E. Pellicer, E. Comini, P. Siciliano, G. Faglia, and J.R. Morante: Synthesis and gas-sensing properties of Pd-doped SnO2 nanocrystals: A case study of a general methodology for doping metal oxide nanocrystals. Cryst. Growth Des. 8, 1774 (2008).

    Article  CAS  Google Scholar 

  10. J.W. Gong, Q.F. Chen, M.R. Lian, N.C. Liu, R.G. Stevenson, and F. Adami: Micromachined nanocrystalline silver doped SnO2 H2S sensor. Sens. Actuators, B 114, 32 (2006).

    Article  CAS  Google Scholar 

  11. A. Kolmakov, D.O. Klenov, Y. Lilach, S. Stemmer, and M. Moskovits: Enhanced gas sensing by individual SnO2 nanowires and nanobelts functionalized with Pd catalyst particles. Nano Lett. 5, 667 (2005).

    Article  CAS  Google Scholar 

  12. X.H. Kong and Y.D. Li: High sensitivity of CuO modified SnO2 nanoribbons to H2S at room temperature. Sens. Actuators, B 105, 449 (2005).

    Article  CAS  Google Scholar 

  13. G. Oldfield, T. Ung, and P. Mulvaney: Au@SnO2 core-shell nanocapacitors. Adv. Mater. 12, 1519 (2000).

    Article  CAS  Google Scholar 

  14. U.S. Choi, G. Sakai, K. Shimanoe, and N. Yamazoe: Sensing properties of Au-loaded SnO2-Co3O4 composites to CO and H2. Sens. Actuators, B 107, 397 (2005).

    Article  CAS  Google Scholar 

  15. R.H.R. Castro, P. Hidalgo, H.E.M. Perez, F.J. Ramirez-Fernandez, and D. Gouvea: Relationship between surface segregation and rapid propane electrical response in Cd-doped SnO2 nanornaterials. Sens. Actuators, B 133, 263 (2008).

    Article  CAS  Google Scholar 

  16. P. Hidalgo, R.H.R. Castro, A.C.V. Coelho, and D. Gouvea: Surface segregation and consequent SO2 sensor response in SnO2-NiO. Chem. Mater. 17, 4149 (2005).

    Article  CAS  Google Scholar 

  17. J.F. Boyle and K.A. Jones: Effect of CO, water-vapor and surface-temperature on conductivity of a SnO2 gas sensor. J. Electron. Mater. 6, 717 (1977).

    Article  CAS  Google Scholar 

  18. P.A. Mulheran and J.H. Harding: The stability of SnO2 surfaces. Modell. Simul.Mater. Sci. Eng. 1, 39 (1992).

    Article  CAS  Google Scholar 

  19. J. Oviedo and M.J. Gillan: Energetics and structure of stoichiometric SnO2 surfaces studied by first-principles calculations. Surf. Sci. 463, 93 (2000).

    Article  CAS  Google Scholar 

  20. Y. Yamaguchi, K. Tabata, and T. Yashima: First-principles calculations on the surface electronic and reactive properties of M/SnO2 (M = Ge, Mn) (110). J. Mol. Struct. 714, 221 (2005).

    Article  CAS  Google Scholar 

  21. R.A. Evarestov, A.V. Bandura, and E.V. Proskurov: Plain DFT and hybrid HF-DFT LCAO calculations of SnO2 (110) and (100) bare and hydroxylated surfaces. Phys. Status Solidi. 243, 1823 (2006) (b).

    Article  CAS  Google Scholar 

  22. M. Batzill, U. Diebold, W. Bergermayer, and I. Tanaka: Tuning the chemical functionality of a gas sensitive material: Water adsorption on SnO2(101). Surf. Sci. 600, 29 (2006).

    Article  Google Scholar 

  23. P. Zhang, F. Xu, A. Navrotsky, J.S. Lee, S.T. Kim, and J. Liu: Surface enthalpies of nanophase ZnO with different morphologies. Chem. Mater. 19, 5687 (2007).

    Article  CAS  Google Scholar 

  24. A.A. Levchenko, G.S. Li, J. Boerio-Goates, B.F. Woodfield, and A. Navrotsky: TiO2 stability landscape: Polymorphism, surface energy, and bound water energetics. Chem. Mater. 18, 6324 (2006).

    Article  CAS  Google Scholar 

  25. W. Zhou, S.V. Ushakov, T. Wang, J.G. Ekerdt, A.A. Demkov, and A. Navrotsky: Hafnia: Energetics of thin films and nanoparticles. J. Appl. Phys. 107, 123514 (2010).

    Article  Google Scholar 

  26. A.V. Radha, O. Bomati-Miguel, S.V. Ushakov, A. Navrotsky, and P. Tartaj: Surface enthalpy, enthalpy of water adsorption, and phase stability in nanocrystalline monoclinic zirconia. J. Am. Ceram. Soc. 92, 133 (2009).

    Article  CAS  Google Scholar 

  27. A. Navrotsky: Progress and new directions in high-temperature calorimetry. Phys. Chem. Miner. 2, 89 (1977).

    Article  CAS  Google Scholar 

  28. A. Navrotsky: Progress and new directions in high-temperature calorimetry revisited. Phys. Chem. Miner. 24, 222 (1997).

    Article  CAS  Google Scholar 

  29. S.V. Ushakov and A. Navrotsky: Direct measurements of water adsorption enthalpy on hafnia and zirconia. Appl. Phys. Lett. 87, 164103 (2005).

    Article  Google Scholar 

  30. G.C.C. Costa, S.V. Ushakov, R.H.R. Castro, A. Navrotsky, and R. Muccillo: Calorimetric measurement of surface and interface enthalpies of yttria-stabilized zirconia (YSZ). Chem. Mater. 22, 2937 (2010).

    Article  CAS  Google Scholar 

  31. R.A. Robie and B.S. Hemingway: Thermodynamic properties of minerals and related substrate at 298.15 K and 1 bar (105 Pascals) pressure and at higher temperature. U.S. Geol. Surv. Bull. 2131, 461 (1995).

    Google Scholar 

Download references

Acknowledgments

This work was supported by the U.S. Department of Energy Grant DE-FG02-05ER15667. The authors acknowledge the assistance of S.V. Ushakov, A.V. Radha, and D. Wu for their help. R. Castro acknowledges UC Davis for start-up funds.

Author information

Authors and Affiliations

  1. Peter A. Rock Thermochemistry Laboratory and NEAT ORU, University of California at Davis, Davis, California, 95616, USA

    Yuanyuan Ma, Ricardo H. R. Castro, Wei Zhou & Alexandra Navrotsky

Authors
  1. Yuanyuan Ma
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Ricardo H. R. Castro
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Wei Zhou
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Alexandra Navrotsky
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Alexandra Navrotsky.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Ma, Y., Castro, R.H.R., Zhou, W. et al. Surface enthalpy and enthalpy of water adsorption of nanocrystalline tin dioxide: Thermodynamic insight on the sensing activity. Journal of Materials Research 26, 848–853 (2011). https://doi.org/10.1557/jmr.2010.97

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1557/jmr.2010.97

Search

Navigation