Summary
Crack-tip deformation has been investigated in pre-cracked samples of core-shell rubber particle modified epoxy resins with different degrees of crosslinking. Light cross linking resulted in cavitation of the modifier, the formation of croids and extensive crack-tip yielding, whereas these deformation mechanisms were suppressed at room T in highly crosslinked specimens. A zone of particle debonding was observed in these latter at high T, but this appeared detrimental to the toughness. Indeed it was possible to increase the toughness in this case by oxygen plasma treatment of the modifier particles.
Similar content being viewed by others
References
McGarry, FJ (1970) Proc. Roy. Soc. Lond. A59: 68.
Rowe, EH, Seibert, AR, Drake, RS (1970) Mod. Plast. 47:110
Bascom, WD, Cottington, RL, Jones, RL, Peyser, P (1975) J. Appl. Polym. Sci. 19: 2545
Lange, FF (1973) Phil. Mag. 22: 983
Evans, AG (1972) Phil. Mag. 26: 1327
Bucknall, CB, Partridge, IK (1983) Polymer 24: 639
Yee, AF, Pearson, RA (1986) J. Mat. Sci. 21: 2462
Kinloch, AJ (1989) In: Riew, CK (ed) Rubber-Toughened Plastics, American Chemical Society, Washington DC (Advances in Chemistry Series 222, p 71)
Yee, FA, Li, D-M, Li, X-W (1993) J. Mat. Sci. 28: 6392
Pearson, RA (1990) Ph.D Thesis, University of Michigan
Sue, H-J (1992) J. Mat. Sci. 27: 3098
Lu, F, Cantwell, WJ, Kausch, H-H To be published in J. Mat. Sci.
Lu, F, Cantwell, WJ, Fischer, M, Kausch, H-H Submitted to J. Mat. Sci. Lett.
Pearson, RA, Yee, AF (1983) Polym. Mater. Sci. Eng. 49: 316
Pearson, RA, Yee, AF (1986) J. Mat. Sci. 24: 2571
Bradley, WL, Schultz, W, Corleto, C, Komatsu, S (1993) In: Riew, CK, Kinloch, AJ (eds) Toughened Plastics I, American Chemical Society, Washington DC (Advances in Chemistry Series 233, p 317)
European Structural Integrity Society test protocol for polymers (1992)
Lu, F (1995) PhD Thesis, EPFL
Sawyer, LC, Grubb, DT (1987) Polymer Microscopy, Chapman & Hall, London
Huang, Y, Kinloch, AJ (1992) J. Mat. Sci. Lett. 11: 484
Yee, AF, Pearson, RA (1989) In: Roulin-Moloney, AC (ed) Fractography and Failure Mechanisms in Polymers and Composites, Elsevier, London (p 291)
Huang, Y, Hunston, DL, Kinloch, AJ, Riew, CK (1993) In: Riew, CK, Kinloch, AJ (eds) Toughened Plastics I, American Chemical Society, Washington DC (Advances in Chemistry Series 233, p 1)
Sue, H-J, Garcia-Meitin, EI, Pickelman, DM, Yang, PC (1993) In: Riew, CK, Kinloch, AJ (eds) Toughened Plastics I, American Chemical Society, Washington DC (Advances in Chemistry Series 233, p 259)
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Lu, F., Plummer, C.J.G., Cantwell, W.J. et al. Toughening mechanisms in modified epoxy resins with different crosslink densities. Polymer Bulletin 37, 399–406 (1996). https://doi.org/10.1007/BF00318074
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF00318074