Abstract
A physicochemical characterization, the irregularity of the surface quantified by the fractal dimension (DS), and the adsorption of copper (Cu(II)) and lead (Pb(II)) of a kaolin clay from aqueous solutions were studied. In addition, the effects of temperature, contact time, pH of solution, and clay mass on copper Cu(II) and Pb(II) adsorption were investigated. In this work, X-ray fluorescence, X-ray diffraction, and Fourier transform infrared spectroscopy were applied to study the composition and structure of the clay studied. The Brunauer–Emmett–Teller theory and the t-plot method were used to calculate the specific surface and porosity, respectively. The fractal analysis showed that the material has an irregular surface, with a very complex pore structure. This material has a very high adsorption capacity, which exceeds 97.5% and 99.95% for Cu(II) an Pb(II), respectively, for all concentrations under normal conditions of pH and temperature (pH7, T = 25 °C). The maximum adsorption capacity calculated by the Langmuir model was 52.63 mg g−1 for copper (Cu). For lead (Pb) ions, the maximum capacity was 57.30 mg g−1. The adsorption process was rapid, as equilibrium was achieved within 10 min for copper at 25 and 50 mg L−1 and within 30 min at 100 mg L−1. For lead (Pb) ions, equilibrium was achieved within the first minute at all concentrations. The kaolin clay has a better affinity for Pb(II) than Cu(II). The Temkin model showed better correlation with the experimental data for this material. The kinetic study demonstrated that Pb(II) and Cu(II) adsorption on kaolin was in a good accordance with the pseudo-second-order kinetic model.
Similar content being viewed by others
References
Tchounwou, P.B.; Yedjou, C.G.; Patlolla, A.K.; Sutton, D.J.: Heavy metal toxicity and the environment. Mol. Clin. Environ. Toxicol. 101, 133–164 (2012)
Gupta, P.; Diwan, B.: Bacterial, bacterial exopolysaccharide mediated heavy metal removal: a review on biosynthesis, mechanism and remediation strategie. Biotechnol. Rep. 13, 7–58 (2017)
Ibrahim, W.M.; Hassan, A.F.; Azab, Y.A.: Biosorption of toxic heavy metals from aqueous solution by Ulva lactuca activated carbon. Egypt. J. Basic Appl. Sci. 3, 241–249 (2016)
Shabani, K.S.; Aredejani, F.D.; Singh, R.N.; Marandi, R.; Soleimanyfar, H.: Numerical modeling of Cu2+ and Mn2+ ions biosorption by Aspergillus niger fungal biomass in a continuous reactor. Arch. Min. Sci. 56(3), 461–476 (2011)
Shabani, K.S.; Ardejani, F.D.; Badii, K.; Olya, M.E.: Preparation and characterization of novel nanomineral for the removal of several heavy metals from aqueous solution batch and continuous systems. Arab. J. Chem. 10, 3108–3127 (2017)
Danil de Namor, A.F.; El Gamouz, A.; Frangie, S.; Martinez, V.; Valiente, L.; Webb, O.A.: Turning the volume down on heavy metals using tuned diatomite. A review of diatomite and modified diatomite for the extraction of heavy metals from water. J. Hazard. Mater. 241–242, 14–31 (2012)
Selim, K.A.; El-Tawil, R.S.; Rostom, M.: Utilization of surface modified phyllosilicate for heavy metals removal from aqueous solutions. Egypt. J. Petrol. 27, 393–401 (2017)
Kamaraj, R.; Ganesan, P.; Lakshmi, J.; Vasudevan, S.: Removal of copper from water by electrocoagulation process—effect of alternating current (AC) and direct current (DC). Environ. Sci. Pollut. Res. 20, 399–412 (2013)
Vasudevan, S.; Lakshmi, J.; Packiyam, M.: Electrocoagulation studies on removal of cadmium using magnesium electrode. J. Appl. Electrochem. 40, 2023–2032 (2010)
Vasudevan, S.; Lakshmi, J.; Sozhan, G.: Electrocoagulation Studies on the Removal of Copper from Water Using Mild Steel electrode. Water Environ. Res. 84, 209–2019 (2012)
Vasudevan, S.; Lakshmi, J.; Layara, J.; Sozhan, G.: Remediation of phosphate-contaminated water by electrocoagulation with aluminum, aluminum alloy and mild steel anodes. Hazard. Mater. 164, 1480–1486 (2009)
Vasudevan, S.; Lakshmi, J.; Vanathi, R.: Electrochemical coagulation for chromium removal: process optimization, kinetics, isotherm and sludge characterization. Clean 38, 9–16 (2010)
Murray, H.H.: Applied Clay Mineralogy, vol. 2, 1st edn. Elsevier Science, Amsterdam (2006)
Saikia, B.J.; Parthasarathy, G.: Fourier transform infrared spectroscopic characterization of Kaolinite from Assam and Meghalaya, Northeastern India. J. Mod. Phys. 1, 206–210 (2010)
Kiros, A.; Gholap, A.V.; Gigante, G.E.: Fourier transform infrared spectroscopic characterization of clay minerals from rocks of Lalibela churches, Ethiopia. Int. J. Phys. Sci. 8(3), 109–119 (2013)
Djomgoue, P.; Njopwouo, D.: FT-IR spectroscopy applied for surface clays characterization. J Surf. Eng. Mater. Adv. Technol. 3, 275–282 (2013)
Diko, M.; Ekosse, G.: Fourier transform infrared spectroscopy and thermal analyses of Kaolinitic Clays from South Africa And Cameroon. J. Ogola Acta Geodyn. Geomater. 13(2), 149–158 (2016)
Vaculikova, L.; Plevova, E.; Vallova, S.; Koutnik, I.: Characterization and differentiation of Kaolinites from selected Czech deposits using infrared spectroscopy and differential thermal analysis. Acta Geodyn. Geomater. 8, 59–67 (2011)
Sing, K.S.W.; Everett, D.H.; Haul, R.A.W.; Moscou, L.; Pierotti, R.A.; Rouquerol, J.: Reporting physisorption data for gas/solid systems. Pure Appl. Chem. 57, 603–619 (1985)
Bergaya, F.; Lagaly, G.: Handbook of Clay Science, 2nd edn. Elsevier B.V, Amsterdam (2013)
Gregg, S.J.; Sing, K.S.W.: Adsorption, Surface Area and Porosity, 2nd edn. Academic Press, London (1982)
Brunauer, S.; Emmett, P.E.; Teller, E.: Adsorption of gases in multimolecular layers. J. Am. Chem. Soc. 60, 309–319 (1938)
Li, A.; Ding, W.; He, J.; Dai, P.; Yin, S.; Xie, F.: Investigation of pore structure and fractal characteristics of organic-rich shale reservoirs: a case study of lower Cambrian Qiongzhusi formation in Malong block of eastern Yunnan Province, South China. Mar. Pet. Geol. 70, 46–57 (2016)
Sing, K.S.W.: The use of gas adsorption for the characterization of porous solids. Colloids Surf. 38, 113–124 (1989)
Sing, K.S.W.: Physisorption of gases by carbon blacks. Carbon 32, 1311–1317 (1994)
Liu, X.; Xiong, J.; Liang, L.: Investigation of pore structure and fractal characteristics of organic-rich Yanchang formation shale in central China by nitrogen adsorption/desorption analysis. J. Nat. Gas Sci. Eng. 22, 62–72 (2015)
Celis, R.; Cornejo, J.; Hermosin, M.C.: Textural properties of synthetic clay-ferrihydrite associations. Clay Miner. 33, 395–407 (1998)
Helmy, A.K.; Ferreiro, E.A.; De Bussetti, S.G.; Peinemann, N.: Surface areas of kaolin, α-Fe2O3 and hydroxy-Al montmorillonite. Colloid Polym. Sci. 276, 539–543 (1998)
Hajnos, M.; Korsunskaia, L.; Pachepsky, Y.: Soil pore surface properties in managed grasslands. Soil Tillage Res. 55, 63–70 (2000)
Zhang, S.; Tang, S.; Tang, D.; Huang, W.; Pan, Z.: Determining fractal dimensions of coal pores by FHH model: problems and effects. J. Nat. Gas Sci. Eng. 21, 929–939 (2014)
Yang, F.; Ning, Z.; Liu, H.: Fractal characteristics of shales from a shale gas reservoir in the Sichuan Basin, China. Fuel 115, 378–384 (2014)
Pfeifer, P.; Cole, M.W.: Fractals in surface science: scattering and thermodynamics of adsorbed films II. New J. Phys. 14, 221–232 (1990)
Sokolowska, Z.; Borowko, M.; Reszko-Zygmunt, J.; Sokolowski, S.: Adsorption of nitrogen and water vapor by alluvial soils. Geoderma 107, 33–54 (2002)
Gonte, R.; Balasubramanian, K.: Heavy and toxic metal uptake by mesoporous hypercrosslinked SMA beads: isotherms and kinetics. J. Saudi Chem. Soc. 20, 579–590 (2016)
Lee, J.Y.; Chen, C.H.; Cheng, S.; Li, H.Y.: Adsorption of Pb(II) and Cu(II) metal ions on functionalized large-pore mesoporous silica. Int. J. Environ. Sci. Technol. 13, 65–76 (2016)
Golkhah, S.; Mousavi, H.Z.; Shirkhan, H.; Khaligh, A.: Removal of Pb(II) and Cu(II) ions from aqueous solutions by cadmium sulfide nanoparticles. Int. J. Nanosci. Nanotechnol. 13(2), 105–117 (2017)
Rafatullah, M.; Sulaiman, O.; Hashim, R.; Ahmad, A.: Adsorption of copper (II), chromium (III), nickel (II) and lead (II) ions from aqueous solutions by meranti sawdust. J. Hazard. Mater. 170, 969–977 (2009)
Yu, B.; Xu, J.; Liu, J.-H.; Yang, S.-T.; Luo, J.; Zhou, Q.; Wan, J.; Liao, R.; Wang, H.; Liu, Y.: Adsorption behavior of copper ions on graphene oxide–chitosan aerogel. J. Environ. Chem. Eng. 1, 1044–1050 (2013)
El Ass, K.: Adsorption of cadmium and copper onto natural clay: isotherm, kinetic and thermodynamic studies. Glob. NEST J. 20(2), 198–207 (2018)
Sari, A.; Tuzen, M.; Soylak, M.; Citak, D.: Equilibrium, kinetic and thermodynamic studies of adsorption of Pb(II) from aqueous solution onto Turkish kaolinite clay. J. Hazard. Mater. 149, 283–291 (2007)
Azzam, A.M.; El-Wakeel, S.T.; Mostafa, B.B.; El-Shahat, M.: Removal of Pb, Cd, Cu and Ni from aqueous solution using nano scale zero valent iron particles. J. Environ. Chem. Eng. (2016). https://doi.org/10.1016/j.jece.2016.03.048
Sana, Z.A.; Makshoof, A.; Muhammad, S.; Muhammad, I.D.: Simultaneous removal of Pb(II), Cd(II) and Cu(II) from aqueous solutions by adsorption on Triticum aestivum a green approach. Hydrol. Curr. Res. 2, 4 (2011)
Jaber, S.: Removal of heavy metals Pb2+, Cu2+, Zn2+, Cd2+, Ni2+, Co2+ and Fe3+ from aqueous solutions by using Xanthium pensylvanicum. Leonardo J. Sci. 2013, 10–97 (2013)
Sheeba Thavamani, S.: Removal of Cr(VI), Cu(II), Pb(II) and Ni(II) from aqueous solutions by adsorption on alumina. Res. J. Chem. Sci. 3(8), 44–48 (2013)
Ali, S.; Athar, M.; Salman, M.; Din, M.I.: Simultaneous removal of Pb(II), Cd(II) and Cu(II) from aqueous solutions by adsorption on Triticum aestivum—a green approach. Hydrol. Curr. Res. 2, 118 (2011). https://doi.org/10.4172/2157-7587.1000118
Demirbas, A.; Sari, A.; Isildak, O.: Adsorption thermodynamics of stearic acid onto bentonite. J. Hazard. Mater. B135, 23–226 (2006)
Liang, L.; He, J.; Wei, M.; Evans, D.G.; Duan, X.: Factors influencing the removal of fluoride from aqueous solution by calcined Mg–Al–CO3 layered double hydroxides. J. Hazard. Mater. B133, 119–128 (2016)
Lazarevic, S.; Jankovic-Castvan, I.; Jovanovic, D.; Milonjic, S.; Janackovic, D.; Petrovic, R.: Adsorption of Pb2+, Cd2+ and Sr2+ ions onto natural and acid-activated sepiolites. Appl. Clay Sci. 37, 47–57 (2007)
McBride, M.B.: Environmental chemistry of soils. Oxford University Press, New York (1994)
Vico, L.: Acid-base behaviour an Cu2+ and Zn2+ complexation properties of the sepiolite/water interface. Chem. Geol. 198, 213–222 (2003)
Lide, D.R.: Handbook of Chemistry and Physics, 79th edn. CRC Press, Boca Raton (1998)
Hillel, D.: Environmental Soil Physics. Academic Press, San Diego (1998)
Amarasinghe, B.M.W.P.K.; Williams, R.A.: Tea waste as a low cost adsorbent for the removal of Cu and Pb from wastewater. Chem. Eng. J. 132, 299–309 (2007)
Ricordel, S.; Taha, S.; Cisse, I.; Dorange, G.: Heavy metals removal by adsorption onto peanut husks carbon: characterization, kinetic study and modeling. Sep. Purif. Technol. 24, 389–401 (2001)
Figen, G.; Bahar, B.: Biosorption of malachite green from an aqueous solution using pomegranate peel: equilibrium modelling, kinetic and thermodynamic studies. J. Mol. Liq. 243, 790–798 (2017)
Orumwense, F.F.O.: Removal of lead from water by adsorption on a kaolinitic clay. J. Chem. Technol. Biotechnol. 65, 363–369 (1996)
Unuabonah, E.I.; Adebowale, K.O.; Olu-Owolabi, B.I.; Yang, L.Z.; Kong, L.X.: Adsorption of Pb(II) and Cd(II) from aqueous solutions onto sodium tetraborate-modified kaolinite clay: equilibrium and thermodynamic studies. Hydrometallurgy 93, 1–9 (2008)
Padilla-Ortega, E.; Leyva-Ramos, R.; Mendoza-Barron, J.; Guerrero-Coronado, R.M.; Jacobo-Azuara, A.; Aragon-Piña, A.: Adsorption of heavy metal ions from aqueous solution onto sepiolite. Adsorpt. Sci. Technol. 29(6), 569–584 (2011)
Chouchane, T.; Yahi, M.; Boukari, A.; Balaska, A.; Chouchane, S.: Adsorption du cuivre en solution par le kaolin. J. Mater. Environ. Sci. 7(8), 2825–2842 (2016)
Al-Degs, Y.S.; El-Barghouthi, M.I.; Issa, A.A.; Khraisheh, M.A.; Walker, G.M.: Sorption of Zn(II), Pb(II), and Co(II) using natural sorbents: equilibrium and kinetic studies. Water Res. 40(26), 45–2658 (2006)
Bhattacharyya, K.G.; Sen Gupta, S.: Removal of Cu(II) by natural and acid-activated clays: an insight of adsorption isotherm, kinetic and thermodynamics. Desalination 272, 66–75 (2011)
Panadare, D.C.; Lade, V.G.; Rathod, V.K.: Adsorptive removal of copper (II) from aqueous solution onto the waste sweet lime peels (SLP): equilibrium, kinetics and thermodynamics studies. Desalin. Water Treat. 52, 7822–7837 (2014)
Lee, C.K.; Low, K.S.; Chew, S.L.: Removal of anionic dyes by water hyacinth roots. Adv. Environ. Res. 3, 343–351 (1999)
Okoronkwo, A.E.; Anwasi, S.: Biosorption modeling of copper and zinc adsorption from aqueous solution by Tithonia diversifolia. In: CSN Conference Proceeding, pp. 92–102. Chemical Society of Nigeria, Deltachem (2008)
Weber, W.J.; Morris, J.C.: Kinetics of adsorption of carbon from solutions. J. Sanit. Eng. Div. Am. Soc. Civ. Eng. 89, 31–63 (1963)
Kaaser, S.; Barrington, S.; Elektorowicz, M.; Wang, L.: Effect of Pb and Cd on Cu adsorption by sand-bentonite 1iners». Can. J. Civ. Eng. 32(1), 241–249 (2005)
Tan, I.A.W.; Ahmad, A.L.; Hameed, B.H.: Adsorption isotherms, kinetics, thermodynamics and desorption studies of 2,4,6-trichlorophenol on oil palm empty fruit bunch-based activated carbon. J. Hazard. Mater. 164, 473–482 (2009)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Bahah, S., Nacef, S., Chebli, D. et al. A New Highly Efficient Algerian Clay for the Removal of Heavy Metals of Cu(II) and Pb(II) from Aqueous Solutions: Characterization, Fractal, Kinetics, and Isotherm Analysis. Arab J Sci Eng 45, 205–218 (2020). https://doi.org/10.1007/s13369-019-03985-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13369-019-03985-6