Abstract
The objective of the study was to characterize the effects of preheating of milk and of pasteurization steps during whey processing on the separation of transforming growth factor-beta 2 (TGF-β2) from whey protein concentrates (WPCs). Three heating conditions were applied to skimmed milk: no heating, 63 °C for 20 s and 68 °C for 20 s. The effect of pasteurizing liquid acid whey and liquid WPC was also assessed. Heating milk at 63 or 68 °C decreased TGF-β2 content of whey. A pasteurization treatment of whey at 72 °C for 15 s further decreased their TGF-β2 content. However, an additional pasteurization of WPCs significantly increased TGF-β2 only in samples from unheated milk. Acid precipitation of WPCs showed that cumulative heat treatments increased the amount of precipitate obtained, and that pH 4.5 was found to be optimal in terms of TGF-β2 content of precipitates. The highest TGF-β2 concentrations in acid precipitates (>10,000 pg.mg−1 solids) were obtained with a combination of heating milk at 63 °C for 20 s and pasteurization of whey at 72 °C for 15 s. It was found that, although whey obtained from raw milk represents the best source of TGF-β2, an appropriate selection of heat treatments of liquid whey and WPC improves the recovery of TGF-β2. The presence of casein and minor whey proteins in TGF-β2-enriched fractions underlines the occurrence of complex heat-induced interactions between TGF-β2 and other milk constituents.
热处理对从酸沉乳清浓缩蛋白中提取TGF-β2回收率的影响
摘要 本文研究了牛乳的预热和乳清的巴氏杀菌过程对从乳清浓缩蛋白中提取TGF-β2回收率的影响。脱脂乳分别经过三种不同的热处理, 分别为未加热、63°C加热20s和68°C加热20s; 同时还评定了巴氏杀菌的液态酸乳清和液态乳清浓缩蛋白中TGF-β2的回收率。脱脂乳的63°C和68oC热处理降低了乳清中TGF-β2的含量; 如果这些乳清再经过72°C、15s的巴氏杀菌处理会进一步降低乳清中TGF-β2的含量。然而对未经热处理的乳清浓缩蛋白溶液进行巴氏杀菌, TGF-β2含量则显著地增加。酸沉乳清浓缩蛋白溶液由于经过多次累加的热处理, 若在pH4.5沉淀乳清蛋白可以获得最大量的TGF-β2。如果脱脂乳在63°C加热20s, 。然后乳清在72°C下加热15s, 可在酸沉乳清浓缩蛋白中获得最高浓度的TGF-β2 (10 000 pg mg–1固体)。尽管生乳乳清是TGF-β2的最佳来源, 但是对乳清和乳清浓缩蛋白进行适度的热处理也可以提高TGF-β2的回收率。热处理导致TGF-β2与其他乳成分之间形成复合物, 使得提取的富含TGF-β2的提取物中含有酪蛋白和一些微量的乳清蛋白。
Similar content being viewed by others
References
Akbache A, Lamiot É, Moroni O, Turgeon S, Gauthier SF, Pouliot Y (2009) Use of membrane processing to concentrate TGF-β2 and IGF-I from bovine milk and whey. J Memb Sci 326:435–440
Akbache A, Rocafi A, Saffon M, Lamiot E, Moroni O, Turgeon SL, Richard C, Gauthier SF, Pouliot Y (2011) Effect of heating on the distribution of TGF-β2 in bovine milk. Food Res Int 44:28–32
Alomirah HF, Alli I (2004) Separation and characterization of β-lactoglobulin and α-lactalbumin from whey and whey protein preparations. Int Dairy J 14:411–419
Anema SG, Klostermeyer H (1997) Heat-induced, pH-dependent dissociation of casein micelles on heating reconstituted skim milk at temperatures below 100 °C. J Agric Food Chem 45:1108–1115
Association of Official Analytical Chemists (1990) Methods 925.23, 945.46. In: Official methods of analysis, 15th edn. Association of Official Analytical Chemists, Washington.
Ben Ounis W, Gauthier SF, Turgeon SL, Roufik S, Pouliot Y (2008) Separation of minor protein components from whey protein isolates by heparin affinity chromatography. Int Dairy J 18:1043–1050
Ben Ounis W, Gauthier SF, Turgeon SL, Pouliot Y (2010) Separation of transforming growth factor-beta2 (TGF-β2) from whey protein isolates by crossflow microfiltration in the presence of a ligand. J Memb Sci 351:189–195
Bramaud C, Aimar P, Daufin G (1995) Thermal isoelectric precipitation of α-lactalbumin from a whey protein concentrate: influence of protein-calcium complexation. Biotechnol Bioeng 47:121–130
Brown PD, Wakefield LM, Levinson AD, Sporn MB (1990) Physicochemical activation of recombinant latent transforming growth factor-beta's 1, 2, and 3. Growth Factors 3:35–43
De Wit JN (1990) Thermal stability and functionality of whey proteins. J Dairy Sci 73:3602–3612
De Wit JN, Klarenbeek G (1984) Effects of various heat treatments on structure and solubility of whey proteins. J Dairy Sci 67:2701–2710
Francis GL, Regester GO, Webb HA, Ballard FJ (1995) Extraction from cheese whey by cation-exchange chromatography of factors that stimulate the growth of mammalian cells. J Dairy Sci 78:1209–1218
Gauthier SF, Pouliot Y, Maubois JL (2006) Growth factors from bovine milk and colostrum: composition, extraction and biological activities. Lait 86:99–125
Gésan-Guiziou G, Daufin G, Timmer M, Allersma D, Van Der Horst C (1999) Process steps for the preparation of purified fractions of α-lactalbumin and β-lactoglobulin from whey protein concentrates. J Dairy Res 66:225–236
International Dairy Federation (2002) Determination of nitrogen content-routine method using combustion according to the Dumas principle. IDF 186, Brussels.
Lachkar DP, Lamiot É, Turgeon SL, Gauthier SF, Paquin P, Pouliot Y (2008) An experimental approach for removing caseins from bovine colostrum using anionic polysaccharides. Int J Dairy Technol 61:43–50
Lachkar DP, Pouliot Y, Gauthier SF, Turgeon S, Lamiot E, Juneau C (2010) Method for selective fractionation of growth factors from dairy products. United States Patent Application 20100121037, 13th May
Larsen LB, Wedholm-Pallas A, Lindmark-Månsson H, Andrén A (2010) Different proteomic profiles of sweet whey and rennet casein obtained after preparation from raw versus heat-treated skimmed milk. Dairy Sci Technol 90:641–656
Maubois JL, Fauquant J, Jouan P, Bourtourault M (2003) Method for obtaining a TGF-β enriched protein fraction in activated form, protein fraction and therapeutic applications. World Patent WO 03/006500 A1, 23rd January
Morr CV, Ha EYW (1993) Whey protein concentrates and isolates: processing and functional properties. Crit Rev Food Sci Nutr 33:431–476
Nielsen SS (1994) Introduction to the chemical analysis of food. Jones & Bartlett, Boston
Outinen M, Heino A, Uusi-Rauva J (2010) Pre-treatment methods of Edam cheese milk. Effect on the whey composition. LWT-Food Sci Technol 43:647–654
Pouliot Y, Gauthier SF (2006) Milk growth factors as health products: some technological aspects. Int Dairy J 16:1415–1420
Rogers ML, Goddard C, Regester GO, Ballard FJ, Belford DA (1996) Transforming growth factor-β in bovine milk: concentration stability and molecular mass forms. J Endocrinol 151:77–86
Acknowledgments
This work was supported by a university-industry grant from the Natural Sciences and Engineering Council (NSERC) of Canada and by Advitech Inc.
Author information
Authors and Affiliations
Corresponding author
About this article
Cite this article
Rocafi, A., Lamiot, É., Moroni, O. et al. Effect of milk thermal history on the recovery of TGF-β2 by acid precipitation of whey protein concentrates. Dairy Science & Technol. 91, 615–627 (2011). https://doi.org/10.1007/s13594-011-0041-6
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13594-011-0041-6
Keywords
- Whey protein concentrate
- Transforming growth factor-beta 2
- Ultrafiltration
- Heat treatments
- Pasteurization