Skip to main content
SpringerLink
Log in

A new combination of microfiltration, powdered activated carbon and coagulation for treatment of oily wastewater

  • Original Paper
  • Published:
International Journal of Environmental Science and Technology Aims and scope Submit manuscript

Abstract

In this paper, home-made mullite and mullite–alumina microfiltration membranes fabricated by extrusion and sintering procedures employed in novel microfiltration-powdered activated carbon–coagulation hybrid process for oily wastewater (or oil-in-water emulsion) treatment. Powdered activated carbon and four types of coagulants: aluminum chloride, aluminum sulfate, ferrous chloride and ferrous sulfate plus equal concentration of calcium hydroxide Ca(OH)2 was added to the oily wastewater in the hybrid process. Powdered activated carbon was used as adsorbent agent in all tests. All experiments were performed under the best operating condition of cross-flow velocity = 1.5 m s−1, transmembrane pressure = 3 bar and temperature = 35 °C. Total organic hydrocarbon rejection and permeate flux of membranes for each test were reported and discussed. Hermia’s models for cross-flow microfiltration were used for prediction of permeate flux reduction with time for both membranes in hybrid process. Average errors between experimental and modeling permeate flux were calculated for each model and compared with the other models. Results showed that by using iron salts, total organic hydrocarbon rejection and permeate flux are higher than aluminum salts for both mullite and mullite–alumina membranes. Cake layer formation is dominant fouling mechanism under all coagulant agents and is in good agreement with experimental permeate flux for mullite and mullite–alumina membranes.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11

Similar content being viewed by others

Abbreviations

A :

Membrane area (m2)

V :

Volume of permeate (L)

C p :

Oil concentration in permeate (mg L−1)

C f :

Oil concentration in feed (mg L−1)

CFV:

Cross-flow velocity (m s−1)

\( d_{p} \) :

Diameter of oil droplets (m)

L :

Tubular membrane length (m)

J :

Permeation flux (PF) (L m−2 h−1)

J 0 :

Initial permeate flux (L m−2 h−1)

K c :

Complete pore-blocking model constant (s−1)

K gl :

Cake layer formation model constant (s m−6)

K i :

Intermediate pore-blocking model constant (m−3)

K s :

Standard pore-blocking model constant (s−3)

n :

Blocking index and compressibility coefficient (-)

TMP:

Transmembrane pressure (bar)

PAC:

Powdered activated carbon

PF:

Permeate flux (L m−2 h−1)

TOC:

Total organic carbon

SEM:

Scanning electron microscopy

XRD:

X-ray diffraction

t :

Filtration time (s)

References

  • Abbasi M, Mowla D (2014) Analysis of membrane pore-blocking models applied to the MF of real oily wastewaters treatment using mullite and mullite–alumina ceramic membranes. Desalin Water Treat 52:2481–2493

    Article  CAS  Google Scholar 

  • Abbasi M, Taheri A (2013) Effect of coagulant agents on oily wastewater treatment performance using mullite ceramic MF membranes: experimental and modeling studies. Chin J Chem Eng 21:1251–1259

    Article  CAS  Google Scholar 

  • Abbasi M, Taheri A (2014) Modeling of coagulation–microfiltration hybrid process for treatment of oily wastewater using ceramic membranes. J Water Chem Technol 36:80–89

    Article  Google Scholar 

  • Abbasi M, Taheri A (2016) Selecting model for treatment of oily wastewater by MF–PAC hybrid process using mullite–alumina ceramic membranes. J Water Chem Technol 38:173–180

    Article  Google Scholar 

  • Abbasi M, Mirfendereski M, Nikbakht M, Golshenas M, Mohammadi T (2010) Performance study of mullite and mullite–alumina ceramic MF membranes for oily wastewaters treatment. Desalination 259:169–178

    Article  CAS  Google Scholar 

  • Abbasi M, Reza Sebzari M, Mohammadi T (2011) Enhancement of oily wastewater treatment by ceramic microfiltration membranes using powder activated carbon. Chem Eng Technol 34:1252–1258

    Article  CAS  Google Scholar 

  • Abbasi M, Salahi A, Mirfendereski M, Mohammadi T, Rekabdar F, Hemmati M (2012) Oily wastewater treatment using mullite ceramic membrane. Desalin Water Treat 37:21–30

    Article  CAS  Google Scholar 

  • Adachi S, Ishimaru M, Sina Y, McHargue CJ, Sickafus KE, Alves E (2015) Corundum-to-spinel structural phase transformation in alumina. Nucl Instrum Methods Phys Res Sect B Beam Interact Mater Atoms 358:136–141

    Article  CAS  Google Scholar 

  • Amosa MK (2016) Towards sustainable membrane filtration of palm oil mill effluent: analysis of fouling phenomena from a hybrid PAC–UF process. Appl Water Sci 7:1–11

    Article  CAS  Google Scholar 

  • Amosa MK, Jami MS, Alkhatib MAFR, Majozi T (2016a) Studies on pore blocking mechanism and technical feasibility of a hybrid PAC–MF process for reclamation of irrigation water from biotreated POME. Sep Sci Technol 51:2047–2061

    Article  CAS  Google Scholar 

  • Amosa MK, Jami MS, Alkhatib MAFR, Majozi T (2016b) Technical feasibility study of a low-cost hybrid PAC–UF system for wastewater reclamation and reuse: a focus on feedwater production for low-pressure boilers. Environ Sci Pollut Res 23:22554–22567

    Article  CAS  Google Scholar 

  • Ang WL, Mohammad AW, Hilal N, Leo CP (2015) A review on the applicability of integrated/hybrid membrane processes in water treatment and desalination plants. Desalination 363:2–18

    Article  CAS  Google Scholar 

  • Boni HT, de Oliveira D, Ulson de Souza AA, Ulson de Souza SMAG (2016) Bioadsorption by sugarcane bagasse for the reduction in oil and grease content in aqueous effluent. Int J Environ Sci Technol 13:1169–1176

    Article  CAS  Google Scholar 

  • Bowen W, Calvo J, Hernandez A (1995) Steps of membrane blocking in flux decline during protein microfiltration. J Membr Sci 101:153–165

    Article  CAS  Google Scholar 

  • de Barros S, Andrade C, Mendes E, Peres L (2003) Study of fouling mechanism in pineapple juice clarification by ultrafiltration. J Membr Sci 215:213–224

    Article  CAS  Google Scholar 

  • Duan J, Gregory J (2003) Coagulation by hydrolysing metal salts. Adv Colloid Interface Sci 100:475–502

    Article  CAS  Google Scholar 

  • Emani S, Uppaluri R, Purkait MK (2014) Cross flow microfiltration of oil–water emulsions using kaolin based low cost ceramic membranes. Desalination 341:61–71

    Article  CAS  Google Scholar 

  • Field R, Wu D, Howell J, Gupta B (1995) Critical flux concept for microfiltration fouling. J Membr Sci 100:259–272

    Article  CAS  Google Scholar 

  • Go G-W, Lee E-J, Kang S, Jang A (2016) Combined coagulation/ceramic membrane ultrafiltration system for reclamation of degreasing washing water. Desalin Water Treat 57:7479–7486

    Article  CAS  Google Scholar 

  • Hermia J (1982) Constant pressure blocking filtration law application to powder-law non-Newtonian fluid. Trans Inst Chem Eng 60:183–187

    CAS  Google Scholar 

  • Hwang K-J, Lin T-T (2002) Effect of morphology of polymeric membrane on the performance of cross-flow microfiltration. J Membr Sci 199:41–52

    Article  CAS  Google Scholar 

  • Ince M, Senturk E, Engin GO, Keskinler B (2010) Further treatment of landfill leachate by nanofiltration and microfiltration–PAC hybrid process. Desalination 255:52–60

    Article  CAS  Google Scholar 

  • Iritani E (2013) A review on modeling of pore-blocking behaviors of membranes during pressurized membrane filtration. Dry Technol 31:146–162

    Article  Google Scholar 

  • Issaoui M, Limousy L, Lebeau B, Bouaziz J, Fourati M (2017) Manufacture and optimization of low-cost tubular ceramic supports for membrane filtration: application to algal solution concentration. Environ Sci Pollut Res 24:9914–9926

    Article  CAS  Google Scholar 

  • Keerthi, Vinduja V, Balasubramanian N (2013) Electrocoagulation-integrated hybrid membrane processes for the treatment of tannery wastewater. Environ Sci Pollut Res 20:7441–7449

    Article  CAS  Google Scholar 

  • Kimura K, Maeda T, Yamamura H, Watanabe Y (2008) Irreversible membrane fouling in microfiltration membranes filtering coagulated surface water. J Membr Sci 320:356–362

    Article  CAS  Google Scholar 

  • Konieczny K, Bodzek M, Rajca M (2006) A coagulation–MF system for water treatment using ceramic membranes. Desalination 198:92–101

    Article  CAS  Google Scholar 

  • Kosvintsev S, Holdich R, Cumming I, Starov V (2002) Modelling of dead-end microfiltration with pore blocking and cake formation. J Membr Sci 208:181–192

    Article  CAS  Google Scholar 

  • Kumar RV, Ghoshal AK, Pugazhenthi G (2015) Elaboration of novel tubular ceramic membrane from inexpensive raw materials by extrusion method and its performance in microfiltration of synthetic oily wastewater treatment. J Membr Sci 490:92–102

    Article  CAS  Google Scholar 

  • Lin J-L, Huang C, Pan JR, Wang D (2008) Effect of Al(III) speciation on coagulation of highly turbid water. Chemosphere 72:189–196

    Article  CAS  Google Scholar 

  • Loong CK, Richardson JW Jr., Ozawa M (1997) Structural phase transformations of rare-earth modified transition alumina to corundum. J Alloy Compd 250:356–359

    Article  CAS  Google Scholar 

  • Matilainen A, Vepsäläinen M, Sillanpää M (2010) Natural organic matter removal by coagulation during drinking water treatment: a review. Adv Colloid Interface Sci 159:189–197

    Article  CAS  Google Scholar 

  • Mozia S, Janus M, Brożek P, Bering S, Tarnowski K, Mazur J, Morawski AW (2016) A system coupling hybrid biological method with UV/O3 oxidation and membrane separation for treatment and reuse of industrial laundry wastewater. Environ Sci Pollut Res 23:19145–19155

    Article  CAS  Google Scholar 

  • Rasouli Y, Abbasi M, Hashemifard SA (2017a) Investigation of in-line coagulation–MF hybrid process for oily wastewater treatment by using novel ceramic membranes. J Clean Prod 161:545–559

    Article  CAS  Google Scholar 

  • Rasouli Y, Abbasi M, Hashemifard SA (2017b) Oily wastewater treatment by adsorption–MF hybrid process using PAC, natural zeolite powder and low cost ceramic membranes. Water Sci Technol 76:895–908

    Article  CAS  Google Scholar 

  • Safari S, Azadi Aghdam M, Kariminia H-R (2016) Electrocoagulation for COD and diesel removal from oily wastewater. Int J Environ Sci Technol 13:231–242

    Article  CAS  Google Scholar 

  • Shirasaki N, Matsushita T, Matsui Y, Urasaki T, Kimura M, Ohno K (2014) Virus removal by an in-line coagulation–ceramic microfiltration process with high-basicity polyaluminum coagulation pretreatment. Water Sci Technol Water Supply 14:429–437

    Article  CAS  Google Scholar 

  • Shivaraju HP, Muzakkira N, Shahmoradi B (2016) Photocatalytic treatment of oil and grease spills in wastewater using coated N-doped TiO2 polyscales under sunlight as an alternative driving energy. Int J Environ Sci Technol 13:2293–2302

    Article  CAS  Google Scholar 

  • Sichinga MC, Frazee J, Tong AZ (2016) Efficiency and kinetics in treatment of wastewater from garages and residential oil spills using membrane bioreactor technology. Int J Environ Sci Technol 13:135–146

    Article  CAS  Google Scholar 

  • Vela MCV, Blanco SÁ, García JL, Rodríguez EB (2008) Analysis of membrane pore blocking models applied to the ultrafiltration of PEG. Sep Purif Technol 62:489–498

    Article  CAS  Google Scholar 

  • Weschenfelder S, Mello A, Borges C, Campos J (2015) Oilfield produced water treatment by ceramic membranes: preliminary process cost estimation. Desalination 360:81–86

    Article  CAS  Google Scholar 

  • Yang Y, Chen R, Xing W (2011) Integration of ceramic membrane microfiltration with powdered activated carbon for advanced treatment of oil-in-water emulsion. Sep Purif Technol 76:373–377

    Article  CAS  Google Scholar 

  • Zhang L-L, Yang D, Zhong Z-J, Gu P (2008) Application of hybrid coagulation–microfiltration process for treatment of membrane backwash water from waterworks. Sep Purif Technol 62:415–422

    Article  CAS  Google Scholar 

  • Zhang H, Zhong Z, Weixing L, Weihong X, Wanqin J (2014) River water purification via a coagulation-porous ceramic membrane hybrid process. Chin J Chem Eng 22:113–119

    Article  CAS  Google Scholar 

Download references

Acknowledgement

The authors would like to thank the National Iranian Oil Refining and Distribution Company (NIORDC) for funding this work.

Author information

Authors and Affiliations

  1. Sustainable Membrane Technology Research Group, Department of Chemical Engineering, Faculty of Oil, Gas and Petrochemical Engineering, Persian Gulf University, P.O. Box 75169-13798, Bushehr, Iran

    Y. Rasouli, M. Abbasi & S. A. Hashemifard

Authors
  1. Y. Rasouli
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. M. Abbasi
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. S. A. Hashemifard
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to M. Abbasi.

Additional information

Editorial responsibility: M. Abbaspour.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Rasouli, Y., Abbasi, M. & Hashemifard, S.A. A new combination of microfiltration, powdered activated carbon and coagulation for treatment of oily wastewater. Int. J. Environ. Sci. Technol. 16, 5595–5610 (2019). https://doi.org/10.1007/s13762-018-1906-5

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13762-018-1906-5

Keywords

Search

Navigation