Abstract
Based on the classical droplet nucleation theory along with the droplet growing model, a dual-fluid model considering the effect of velocity-slip between the liquid phase and the gaseous phase is proposed in this paper. Both 2-D and 3-D numerical simulations were then implemented, respectively, on the flow in low pressure cascade and the result showed that this dual-fluid model was provided with relatively high resolution and good reliability on capturing the typical flow characteristics, such as the “Wilson Point” and the “Condensing Shock” (Li Dissertation Submitted to Xi’an Jiaotong University In partial fulfillment of the requirement for the degree of Doctor of Philosophy 1–2, 2002). In addition, both of the 2-D investigation and 3-D investigation implied that the non-equilibrium condensation had great impact on the parameter distribution as well as the loss of the flow field. Meanwhile, because the radius of droplets generated during the condensation might be quite small, the velocity-slip between the liquid phase and the gaseous phase almost has no influence on the flow field compared with condensation.
Similar content being viewed by others
Abbreviations
- T s(p) :
-
Saturate temperature (K)
- T d :
-
Temperature of liquid phase (K)
- T :
-
Temperature of gaseous phase (K)
- \(\dot{m}\) :
-
Mass generation rate (kg/(m3 s))
- ρ :
-
Density of gaseous phase (kg/m3)
- ρ p :
-
Density of liquid phase (kg/m3)
- ρ m :
-
Density of mixed phase (kg/m3)
- P :
-
Local static pressure (Pa)
- P 01 :
-
Inlet total pressure (Pa)
- P 02 :
-
Local total pressure (Pa)
- h fg :
-
Latent heat of vaporization (J/kg)
- h t :
-
Total enthalpy of gaseous phase (J/kg)
- τ rp :
-
Drag coefficient, \(\tau_{rp} = \frac{{d_{p}^{2} \rho_{\text{p}} }}{18\mu }\left( {1 + \frac{1}{6}{\text{Re}}_{p}^{{{\raise0.7ex\hbox{$2$} \!\mathord{\left/ {\vphantom {2 3}}\right.\kern-0pt} \!\lower0.7ex\hbox{$3$}}}} } \right)^{ - 1}\)(–)
- G :
-
Cunningham correction factor (–)
- I :
-
Nucleation rate (/kg)
- N :
-
Droplet number (/kg)
- r :
-
Radius of droplets (m)
- r * :
-
Critical radius of droplets (m)
- q c :
-
Coefficient of condensation (–)
- K b :
-
Boltzmann’s constant (=1.3807 × 10−23J/kg)
- M m :
-
Molecular mass of water (kg)
- σ :
-
Surface tension coefficient (N/m)
- θ :
-
Non-isothermal correction coefficient (–)
- γ :
-
Volumetric ratio of specific heats (–)
- R :
-
Gas constant (=461.4 J/(kg K))
- C p :
-
Specific heat at constant pressure (J/(kg K))
References
Li L (2002) Numerical study on the non- equilibrium wet steam two-phase flows with spontaneous condensation. Dissertation Submitted to Xi’an Jiaotong University In partial fulfillment of the requirement for the degree of Doctor of Philosophy, pp 1–2
Li L, Feng ZP, Li GJ (2001) Numerical simulation of two phase wet steam transonic flow with spontaneous condensation in a l-D nozzle. J Eng Thermophys 22(6):703–705
Moore MJ, Sieverding CH (1976) Two-phase steam (Moore and Sieverding 1976) flow in turbines and separators. Hemi Sphere Publishing Corporation
Moore MJ, Sieverding CH (1986) Aerothermodynamics of low pressure steam turbines and condensers. Hemi Sphere Publishing Corporation
Wu XM, Li L, Li GJ (2007) A three-dimensional numerical simulation of wet steam condensation flows based on a dual fluid model. J Eng Therm Energy Power 22(4):367–370
Gosman AD, Loannides E (1981) Aspect of computer simulation of liquid-fuelled combustion//AIAA 19th Aerospace Science Meeting. St Louis: McGraw Hill, pp 1285–1293
Lin ZR (2005) Investigation of real gas flows within steam and gas turbines. Dissertation for the Degree of Doctor in Tsinghua University, April
Lin ZR, Yuan X (2005) Numerical simulation of equilibrium wet steam flow inside stator blade of turbine last stage. J Eng Thermophys 26(3):417–419
Yu XF (2011) A numerical simulation of wet steam flow based on dual fluid model. Dissertation for the Degree of Master in Harbin Institute of Technology, June
Zhou LX (1991) Theory and numerical modeling of turbulent gas-particle flows and combustion. Tsinghua University Press, Beijing
Guha A, Young JB (1991) Time-Marching prediction of unsteady condensation phenomena due to supercritical heat addition. I mech E paper C423/057. In: Proceedings of Conference Turbo machinery: Latest development in a Changing Scene. London, England, pp 167–177
Hill PG (1966) Condensation of water vapor during supersonic expansion in nozzles. J Fluid Mech 25:593–620
White AJ, Young JB, Walters PT (1996) Experimental validation of condensing flow theory for a stationary cascade of steam turbine blades. Philos Trans R Soc Ser A 354:59–88
Acknowledgments
The authors are very grateful to Doctor LIU Huaping in HIT for their very helpful guidance. Besides, the research presented in this article is funded by the Research Groups of the National Natural Science Foundation of China (Grant no. 51121004) as well as the National Natural Foundation of China (Grant no. 50976026).
Author information
Authors and Affiliations
Corresponding author
Additional information
Technical Editor: Fernando Alves Rochinha.
Rights and permissions
About this article
Cite this article
Cui, K., Song, Y., Chen, H. et al. Numerical method for non-equilibrium phase transition in low pressure stage of steam turbine. J Braz. Soc. Mech. Sci. Eng. 38, 2149–2159 (2016). https://doi.org/10.1007/s40430-015-0452-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40430-015-0452-z