Abstract
In this study, crystal orientation and polymorphism formation in electrospun poly(vinylidene fluoride) (PVDF)/polyacrylonitrile (PAN) blend fibers after melt-recrystallization were studied. To achieve uniform alignment of electrospun fibers, mechanical stretching was applied to the as-spun nonwoven fibers at 110 °C. Pure ferroelectric β-PVDF crystals in the PAN matrix were achieved, and both polar β-PVDF and polar PAN crystals oriented with their chain axes parallel to the fiber axes. After melt-recrystallization of PVDF, a significant amount of ferroelectric β crystals was retained in addition to the formation of nonpolar α crystals. A polarized Fourier transform infrared study showed that the degree of orientation of ferroelectric β-PVDF crystals was higher than that of nonpolar α crystals, suggesting that the β-PVDF crystals should form at the PVDF/PAN interfaces because of strong dipolar and hydrogen bonding interactions between vinylidene fluoride and acrylonitrile units. The nonpolar α-PVDF crystals should form in the center of PVDF domains.
Similar content being viewed by others
References
H.S. Nalwa: Ferroelectric Polymers: Chemistry, Physics, and Applications (Marcel Dekker, New York, 1995).
S. Ducharme, T.J. Reece, C.M. Othon, and R.K. Rannow: Ferroelectric polymer Langmuir-Blodgett films for nonvolatile memory applications. IEEE Trans. Device Mater. Reliab. 5, 720 (2005).
Q.D. Ling, D.J. Liaw, C. Zhu, D.S.H. Chan, E.T. Kang, and K.G. Neoh: Polymer electronic memories: Materials, devices and mechanisms. Prog. Polym. Sci. 33, 917 (2008).
Z. Hu, M. Tian, B. Nysten, and A.M. Jonas: Regular arrays of highly ordered ferroelectric polymer nanostructures for non-volatile low-voltage memories. Nat. Mater. 8, 62 (2009).
R.C.G. Naber, K. Asadi, P.W.M. Blom, D.M. de Leeuw, and B. de Boer: Organic nonvolatile memory devices based on ferroelectricity. Adv. Mater. 22, 933 (2010).
T. Furukawa, Y. Takahashi, and T. Nakajima: Recent advances in ferroelectric polymer thin films for memory applications. Curr. Appl. Phys. 10, E62 (2010).
Q.X. Chen and P.A. Payne: Industrial applications of piezoelectric polymer transducers. Meas. Sci. Technol. 6, 249 (1995).
Q.M. Zhang, H. Li, M. Poh, F. Xia, Z.Y. Cheng, H. Xu, and C. Huang: An all-organic composite actuator material with a high-dielectric constant. Nature 419, 284 (2002).
P. Brochu and Q. Pei: Advances in dielectric elastomers for actuators and artificial muscles. Macromol. Rapid Commun. 31, 10 (2010).
B. Chu, X. Zhou, K. Ren, B. Neese, M. Lin, Q. Wang, F. Bauer, and Q.M. Zhang: A dielectric polymer with high electric energy density and fast discharge speed. Science 313, 1887 (2006).
X. Zhou, B. Chu, B. Neese, M. Lin, and Q.M. Zhang: Electrical energy density and discharge characteristics of a poly(vinylidene fluoride-chlorotrifluoroethylene) copolymer. IEEE Trans. Dielectr. Electr. Insul. 14, 1133 (2007).
F. Guan, J. Pan, J. Wang, Q. Wang, and L. Zhu: Crystal orientation effect on electric energy storage in poly(vinylidene fluoride-co-hexafluoropropylene) copolymers. Macromolecules 43, 384 (2010).
F. Guan, J. Wang, J. Pan, Q. Wang, and L. Zhu: Effects of polymorphism and crystallite size on dipole reorientation in poly(vinylidene fluoride) and its random copolymers. Macromolecules 43, 6739 (2010).
F. Guan, J. Wang, L. Yang, K. Han, Q. Wang, and L. Zhu: Confinement-induced high field antiferroelectric-like behavior in a poly(vinylidene fluoride-co-trifluoroethylene-co-chlorotrifluoroethylene)-graft-polystyrene graft copolymer. Macromolecules 44, 2190 (2011).
F. Guan, J. Wang, L. Yang, B. Guan, K. Han, Q. Wang, and L. Zhu: Confined ferroelectric properties in poly(vinylidene fluoride-co-chlorotrifluoroethylene)-graft-polystyrene graft copolymers for electric energy storage applications. Adv. Funct. Mater. 21, 3176 (2011).
K. Tashiro: Crystal structure and phase transition of PVDF and related copolymers, in Ferroelectric Polymers: Chemistry, Physics, and Applications, edited by H.S. Nalwa (Marcel Dekker, New York, 1995), p. 63.
A.J. Lovinger: Ferroelectric polymers. Science 220, 1115 (1983).
R. Gregorio and M. Cestari: Effect of crystallization temperature on the crystalline phase content and morphology of poly(vinylidene fluoride). J. Polym. Sci., Part B: Polym. Phys. 32, 859 (1994).
G. Zhong, L. Zhang, R. Su, K. Wang, H. Fong, and L. Zhu: Understanding polymorphism formation in electrospun fibers of immiscible poly(vinylidene fluoride) blends. Polymer 52, 2228 (2011).
H. Benkhati, T.T.M. Tan, and B.J. Jungnickel: Transcrystallization kinetics of poly(vinylidene fluoride). J. Polym. Sci., Part B: Polym. Phys. 39, 2130 (2001).
A.J. Lovinger: Crystallization of the β phase of poly(vinylidene fluoride) from the melt. Polymer 22, 412 (1981).
A.J. Lovinger: Unit-cell of the γ phase of poly(vinylidene fluoride). Macromolecules 14, 322 (1981).
A.J. Lovinger: Conformational defects and associated molecular motions in crystalline poly(vinylidene fluoride). J. Appl. Phys. 52, 5934 (1981).
T. Miyazaki, Y. Takeda, M. Akasaka, M. Sakai, and A. Hoshiko: Preparation of isothermally crystallized γ-form poly(vinylidene fluoride) films by adding a KBr powder as a nucleating agent. Macromolecules 41, 2749 (2008).
L. Priya and J.P. Jog: Poly(vinylidene fluoride)/clay nanocomposites prepared by melt intercalation: Crystallization and dynamic mechanical behavior studies. J. Polym. Sci., Part B: Polym. Phys. 40, 1682 (2002).
J. Buckley, P. Cebe, D. Cherdack, J. Crawford, B.S. Ince, M. Jenkins, J. Pan, M. Reveley, N. Washington, and N. Wolchover: Nanocomposites of poly(vinylidene fluoride) with organically modified silicate. Polymer 47, 2411 (2006).
D.R. Dillon, K.K. Tenneti, C.Y. Li, F.K. Ko, I. Sics, and B.S. Hsiao: On the structure and morphology of polyvinylidene fluoride-nanoclay nanocomposites. Polymer 47, 1678 (2006).
D. Shah, P. Maiti, E. Gunn, D.F. Schmidt, D.D. Jiang, C.A. Batt, and E.R. Giannelis: Dramatic enhancements in toughness of polyvinylidene fluoride nanocomposites via nanoclay-directed crystal structure and morphology. Adv. Mater. 16, 1173 (2004).
T. Wu, T. Xie, and G. Yang: Characterization of poly(vinylidene fluoride)/Na+-MMT composites: An investigation into the β-crystalline nucleation effect of Na+-MMT. J. Polym. Sci., Part B: Polym. Phys. 47, 903 (2009).
L. He, Q. Xu, C. Hue, and R. Song: Effect of multi-walled carbon nanotubes on crystallization, thermal, and mechanical properties of poly(vinylidene fluoride). Polym. Compos. 31, 921 (2010).
G.H. Kim, S.M. Hong, and Y. Seo: Piezoelectric properties of poly(vinylidene fluoride) and carbon nanotube blends: β-Phase development. Phys. Chem. Chem. Phys. 11, 10506 (2009).
Y. Li and A. Kaito: Mechanistic investigation into the unique orientation textures of poly(vinylidene fluoride) in blends with nylon 11. Macromol. Rapid Commun. 24, 603 (2003).
Y. Li and A. Kaito: Crystallization and orientation behaviors of poly(vinylidene fluoride) in the oriented blend with nylon 11. Polymer 44, 8167 (2003).
K.J. Kim, H.W. Cho, and K.J. Yoon: Effect of P(MMA-co-MAA) compatibilizer on the miscibility of nylon 6/PVDF blends. Eur. Polym. J. 39, 1249 (2003).
A. Kaito, Y. Iwakura, Y. Li, K. Nakayama, and H. Shimizu: Unique orientation textures induced by confined crystal growth of poly(vinylidene fluoride) in oriented blends with polyamide 6. Macromol. Chem. Phys. 208, 504 (2007).
B. Na, W. Xu, R. Lv, Z. Li, N. Tian, and S. Zou: Toughening of nylon-6 by semicrystalline poly(vinylidene fluoride): Role of phase transformation and fibrillation of dispersed particles. Macromolecules 43, 3911 (2010).
C. Lai, G. Zhong, Z. Yue, G. Chen, L. Zhang, A. Vakili, Y. Wang, L. Zhu, J. Liu, and H. Fong: Investigation of post-spinning stretching process on morphological, structural, and mechanical properties of electrospun polyacrylonitrile copolymer nanofibers. Polymer 52, 519 (2011).
F.M. Li, K.H. Kim, J.J. Kulig, E.P. Savitski, W.J. Brittain, F.W. Harris, S.Z.D. Cheng, S.F. Hubbard, and K.D. Singer: High-temperature aromatic polyimide film displaying nonlinear-optical 2nd-harmonic generation based on the approach of the poled guest-host system. J. Mater. Chem. 5, 253 (1995).
H.N. Na, X.W. Liu, J.Q. Li, Y.H. Zhao, C. Zhao, and X.Y. Yuan: Formation of core/shell ultrafine fibers of PVDF/PC by electrospinning via introduction of PMMA or BTEAC. Polymer 50, 6340 (2009).
H.N. Na, X.W. Liu, H. Sun, Y.H. Zhao, C. Zhao, and X.Y. Yuan: Electrospinning of ultrafine PVDF/PC fibers from their dispersed solutions. J. Polym. Sci., Part B: Polym. Phys. 48, 372 (2010).
G. Zhong, K. Wang, L. Zhang, Z-M. Li, H. Fong, and L. Zhu: Nanodroplet formation and exclusive homogenously nucleated crystallization in confined electrospun immiscible polymer blend fibers of polystyrene and poly(ethylene oxide). Polymer 52, 5397 (2011).
B.G. Colvin and P. Storr: Crystal-structure of polyacrylonitrile. Eur. Polym. J. 10, 337 (1974).
X.D. Liu and W. Ruland: X-Ray studies on the structure of polyacrylonitrile fibers. Macromolecules 26, 3030 (1993).
A. Gradys, P. Sajkiewicz, S. Adamovsky, A. Minakov, and C. Schick: Crystallization of poly(vinylidene fluoride) during ultra-fast cooling. Thermochim. Acta 461, 153 (2007).
M. Kobayashi, K. Tashiro, and H. Tadokoro: Molecular vibrations of three crystal forms of poly(vinylidene fluoride). Macromolecules 8, 158 (1975).
Q. Gao and J. Scheinbeim: Crystallization studies of polymer blends of nylon-11/poly(vinylidene fluoride). Polym. J. 35, 345 (2003).
Acknowledgment
This work was supported by National Science Foundation (DMR-0907580). R. Su and G. Zhong acknowledge the Chinese Scholar Council for financial support. The authors thank Professor Gary Wnek and Mr. Linghui Meng at Case Western Reserve University for helping with electrospinning.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Su, R., Zhong, G., Fu, Q. et al. Polarity-induced ferroelectric crystalline phase in electrospun fibers of poly(vinylidene fluoride)/polyacrylonitrile blends. Journal of Materials Research 27, 1389–1398 (2012). https://doi.org/10.1557/jmr.2012.56
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1557/jmr.2012.56