Abstract
Roman cement was extensively used to decorate façades during the nineteenth and at the beginning of the twentieth century. Interest in this material has revived recently for the conservation of architectural Cultural Heritage, using new production sources. This article gives preliminary results on the characterisation of the raw materials and the main reactive phases (using XRD, SEM, selective dissolution and isothermal calorimetry) of a Roman cement recently produced from the Lilienfeld marlstone (Austria), compared with a commercial Roman cement (Vicat, France). The mineralogical composition of the two cements differs strongly due to the presence of sulphate minerals in the marlstone and on the temperature of calcination. Isothermal calorimetry and in-situ XRD carried out on cement pastes allow the identification of the AFm and AFt type phases as early age hydration products responsible for the flash setting typical to Roman cements. The alumina rich composition and the polymorphs of dicalcium silicates is strongly different in the Lilienfeld cement. This influences their reactivity at the later ages.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
References
Royer, A.: Le “ciment romain” en France: un matériau du XIXe siècle méconnu. Monumental Semester 2, 90–95 (2006)
Hughes, D.C., Swann, S., Gardner, A.: Roman cement: part one: its origins and properties. J. Archit. Conserv. 13(1), 21–36 (2007)
Blezard, R.G.: History of calcareous cement, Chapter 1. In: Hewlett, P.C. (ed.) Lea’s Chemistry of Cement and Concrete, 4th edn. Edward Arnold, London (1998)
Weber, J., Gadermayr, N., Bayer, K., et al.: Roman cement mortars in Europe’s architectural heritage of the 19th century. ASTM Spec. Tech. Publ. 1494, 69–83 (2008)
Weber, J., Gadermayr, N., Kozlowski, R., et al.: Microstructure and mineral composition of Roman cements produced at defined calcination conditions. Mater. Charact. 58(11–12), 1217–1228 (2007)
Hughes, D.C., Swann, S., Gardner, A.: Roman cement – Part Two: stucco and decorative elements, a conservation strategy. J. Archit. Conserv. 13(3), 41–58 (2007)
Adamski, G., Bratasz, L., Kozlowski, R., et al.: Roman cement – key historic material to cover the exteriors of buildings. In: Groot, C. (ed.) Workshop Repair Mortars for Historic Masonry, pp. 2–11. RILEM, Delft (2006)
Gosselin, C., Verges-Belmin, V., Royer, A., et al.: Natural cement and monumental restoration. Mater. Struct./Materiaux et Constructions 42(6), 749–763 (2009)
Cailleux, E., Marie-Victoire, E., Sommain, D.: Study of natural cements from the French Rhône-Alpes region. In: Proceedings of the International Conference on Heritage, Weathering and Conservation, HWC 2006, pp. 77–84 (2006)
Sommain, D.: La durabilité des bétons de ciment prompt naturel, Chapitre 15. In: ENPC (ed.) La durabilité des bétons, 2nd edn Presses de l’école nationale des Ponts et Chaussées (ENPC) (2008)
Avenier, C., Rosier, B., Sommain, D.: Ciment naturel. Glénat, Grenoble (2007)
Hughes, D.C., Jaglin, D., Kozlowski, R., et al.: Calcination of marls to produce Roman cement. J. ASTM Int. 4(1) (2007)
Hughes, D.C., Jaglin, D., Kozlowski, R., et al.: Roman cements – belite cements calcined at low temperature. Cem. Concr. Res. 39(2), 77–89 (2009)
Hughes, D.C., Sugden, D.B., Jaglin, D., et al.: Calcination of Roman cement: a pilot study using cement-stones from Whitby. Construct. Build Mater. 22(7), 1446–1455 (2008)
Tislova, R., Kozlowska, A., Kozlowski, R., et al.: Porosity and specific surface area of Roman cement pastes. Cem. Concr. Res. 39(10), 950–956 (2009)
Stutzman, P.E., Leigh, S.: Phase Composition Analysis of the NIST Reference Clinkers by Optical Microscopy and X-ray Powder Diffraction. NIST Technical Note 1441 (2002)
Costoya, M.M.: Effect of particle size on the hydration kinetics and microstructural development of tricalcium silicate. PhD, Ecole Polytechnique Fédérale de Lausanne (2008)
Taylor, H.F.W.: Cement Chemistry. Thomas Telford Publishing, London (1997)
Bolio-Arceo, H., Glasser, F.P.: Formation of spurrite, Ca5(SiO4)2CO3. Cem. Concr. Res. 20(2), 301–307 (1990)
Vyskocilova, R., Schwarz, W., Mucha, D., et al.: Hydration processes in pastes of Roman and American natural cements. ASTM Spec. Tech. Publ. 1494, 96–104 (2008)
Acknowledgements
This study was initiated in the frame of the Rocare project (EU 226898) and financially supported by the European Commission (FP7-ENV-2008-1 program).
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 2012 RILEM
About this paper
Cite this paper
Gosselin, C., Scrivener, K.L., Feldman, S.B., Schwarz, W. (2012). The Hydration of Modern Roman Cements Used for Current Architectural Conservation. In: Válek, J., Hughes, J., Groot, C. (eds) Historic Mortars. RILEM Bookseries, vol 7. Springer, Dordrecht. https://doi.org/10.1007/978-94-007-4635-0_23
Download citation
DOI: https://doi.org/10.1007/978-94-007-4635-0_23
Published:
Publisher Name: Springer, Dordrecht
Print ISBN: 978-94-007-4634-3
Online ISBN: 978-94-007-4635-0
eBook Packages: EngineeringEngineering (R0)